J&R 700E - Oyler with Exhaust Hood Vent; Figure 5

60 pages

Save Page as PDF

To Next Page

To Next Page

To Previous Page

To Previous Page

Loading...

Oyler With Exhaust Hood Vent

Unit shown is a Model 700-Left Firebox

Figure 5

26

Table of Contents

Warnings3
Disposal of Ashes3
Dedicated Flue3
Table of Contents7
Cook Modes8
Standard Cook Mode8
Dual Fuel Mode8
Cook and Hold Mode9
Important Maintenance Note9
Foundation11
I Nstallation Instructions11
- Handling11
- Shipping11
- Drain11
- Exterior Installation12
- Through the Wall Installation12
- Electrical12
- Clearances12
- Venting Requirements13
- Direct Venting13
- Air Balance14
- Combustion Air14
- Exhaust Hood Venting14
- Meat Racks and Hangers16
- Building a Fire18
- Opening the Oven Doors18
- Start-Up18
Operating Instructions18
- Meat Loading19
- Suggested Cooking Times and Temperatures20
- Grease20
- Firebox Ashes20
- Pit Design21
- Maintenance Schedule21
- Oven Interior21
Maintenance and Cleaning21
- Preventive Maintenance Check List22
- Bearings22
- Chain22
- Exit Flue Cleaning22
- Door Gaskets23
- Combustion Air Damper and Exit Flue Fails to Open and Close24
- Adequate Cooking Temperatures Cannot be Maintained24
Troubleshooting24
- Rotisserie Does Not Revolve26
- Rotisserie Not Revolving Smoothly27
- Product Is Cooking too Fast or too Slow28
- Oyler Interior Installation with Direct Vent29
Figure 129
Oyler Through-The-Wall Installation with Direct Vent31
Figure 331
Oyler with Exhaust Hood Vent33
- Figure 533
- Exhaust Hood Design34
- Smokestack Installation35
- Damper Actuators37
- Wiring Diagram39
- General43
- Installation43
- Mounting Bulb and Capillary43
- To Surface Mount43
- Adjustments44
- Dual Switch Type 80244
- Single Switch Type 80044
- Wiring44
F Igure 7 -Damper Actuators52
- Typical Applications53
- Wiring Diagrams53
- Typical Wiring for MA-305 and MA-405 Series53
- Typical Wiring for MA-318, MA-416, MA-418, and MA-419 Series53
- Action of Auxiliary Switch54
- Power Wire Selection54
- Theory of Operation54
- Checkout54
- General Specifications55
- Contact Ratings55
- Temperature Derating Curves55
- Switch Setting55
- Operation Chart56
- Internal Connections56
- Range Selection57
- ON-Delay57
- Signal Start/Signal Reset57
Warranty58