J&R 700E - Page 60

60 pages

Save Page as PDF

To Previous Page

To Previous Page

Loading...

Table of Contents

Warnings3
Disposal of Ashes3
Dedicated Flue3
Table of Contents7
Cook Modes8
Standard Cook Mode8
Dual Fuel Mode8
Cook and Hold Mode9
Important Maintenance Note9
Foundation11
I Nstallation Instructions11
- Handling11
- Shipping11
- Drain11
- Exterior Installation12
- Through the Wall Installation12
- Electrical12
- Clearances12
- Venting Requirements13
- Direct Venting13
- Air Balance14
- Combustion Air14
- Exhaust Hood Venting14
- Meat Racks and Hangers16
- Building a Fire18
- Opening the Oven Doors18
- Start-Up18
Operating Instructions18
- Meat Loading19
- Suggested Cooking Times and Temperatures20
- Grease20
- Firebox Ashes20
- Pit Design21
- Maintenance Schedule21
- Oven Interior21
Maintenance and Cleaning21
- Preventive Maintenance Check List22
- Bearings22
- Chain22
- Exit Flue Cleaning22
- Door Gaskets23
- Combustion Air Damper and Exit Flue Fails to Open and Close24
- Adequate Cooking Temperatures Cannot be Maintained24
Troubleshooting24
- Rotisserie Does Not Revolve26
- Rotisserie Not Revolving Smoothly27
- Product Is Cooking too Fast or too Slow28
- Oyler Interior Installation with Direct Vent29
Figure 129
Oyler Through-The-Wall Installation with Direct Vent31
Figure 331
Oyler with Exhaust Hood Vent33
- Figure 533
- Exhaust Hood Design34
- Smokestack Installation35
- Damper Actuators37
- Wiring Diagram39
- General43
- Installation43
- Mounting Bulb and Capillary43
- To Surface Mount43
- Adjustments44
- Dual Switch Type 80244
- Single Switch Type 80044
- Wiring44
F Igure 7 -Damper Actuators52
- Typical Applications53
- Wiring Diagrams53
- Typical Wiring for MA-305 and MA-405 Series53
- Typical Wiring for MA-318, MA-416, MA-418, and MA-419 Series53
- Action of Auxiliary Switch54
- Power Wire Selection54
- Theory of Operation54
- Checkout54
- General Specifications55
- Contact Ratings55
- Temperature Derating Curves55
- Switch Setting55
- Operation Chart56
- Internal Connections56
- Range Selection57
- ON-Delay57
- Signal Start/Signal Reset57
Warranty58