Jayco Designer Series User Manual

CHAPTER VII
ANICAL MAINTENANCE CHART
Your new Jayco coach is designed to be as maintenance free as
possible. However, maintenance is important to retain its original
production
as near new as possible. Proper maintenance will give
you many more trouble-free miles.
1
NOTE: Some areas in this &aptex: may not be applicable to
your coach.
COMPONENT MAINTENANCE
Wheel
Bearings
The wheel bearings in your
new Jayco travel trailer or
fifth wheel coach are pre-
greased.
It is recommended
that
you repack these bear-
ings at
5000 miles or at the
end
of each season's camping
to prepare
for winter months
ahead.
Be sure to use only a
multi-purpose No. 1 or 2
good quality wheel bearing
grease.
If bearing or cone (race)
become
pitted, please re-
glace
any damaged part.
NOTE: Should you be
concerned about heat in
wheel bearings, check
them
occasionally while traveling
by $acing hand
on hub. You
will be able to hold your hand
momentarily
on the hub.
Should it be extremely hot, it
is recommended to have the
bearings inspected
by a
qualified service center.
(a.) Exposure to
any water or
condensation
will cause bear-
ings to rust and
be damaged.
(b.) Never let
bearings run
dry.
(c.) Never over-
pack wheel
bearing,
especially
in the
middle
of hub. 1%
wiIl trap heat if
overpacked.

Jayco Designer Series Specifications

General

Type	Caravan
Gas Capacity	Varies by model (e.g., 2 x 9kg bottles)
Heating and Cooling	Air conditioning, heating system
Ball Weight	Varies by model (e.g., 180kg to 250kg)
Water Capacity	Varies by model (e.g., 100L to 200L)