Johnson Controls York Smart Equipment SC-EQ - Table of Contents

JOHNSON CONTROLS
5
FORM 450.50-N1
ISSUE DATE: 08/19/2019
TABLE OF CONTENTS
SECTION 1 - INTRODUCTION .................................................................................................................................9
Overview ..........................................................................................................................................................9
Emissions Compliance ..................................................................................................................................10
SECTION 2 - INSTALLATION ................................................................................................................................ 11
Wiring ............................................................................................................................................................. 11
Protection of Communication Ports ............................................................................................................... 11
High Noise Environments ............................................................................................................................... 12
Electrical Noise Mitigation to Equipment .......................................................................................................12
Electrical Noise Mitigation SC-EQ to BAS ......................................................................................................12
Types of Communication Ports ......................................................................................................................12
Network Termination .......................................................................................................................................12
Media Access Control (MAC) Address ...........................................................................................................13
BAS Network Wiring ....................................................................................................................................... 14
Mounting ........................................................................................................................................................15
OptiView Panel Installation .............................................................................................................................15
Small Tonnage Panel Installation ...................................................................................................................16
YMAA, YCAE, and YCWE-E Panel Installation ..............................................................................................17
YVWE and YVWH Panel Installation ..............................................................................................................20
YEWS and YGWE Single Panel Installation...................................................................................................20
Other Chiller Panel Installation ....................................................................................................................... 21
Mounting on a Micro Panel .............................................................................................................................22
Wall Mounting ................................................................................................................................................. 23
Applying Power ..............................................................................................................................................23
Equipment Configuration ................................................................................................................................ 25
Setting the Rotary Switch on Chiller Panels .................................................................................................. 25
SECTION 3 - TROUBLESHOOTING ......................................................................................................................33
LED Indicators ................................................................................................................................................ 33
Multimeter Checks of the BAS Port ................................................................................................................ 34
Updating the Firmware and the Software ....................................................................................................... 35
Repair Information .......................................................................................................................................... 36
SECTION 4 - SC-AP GATEWAY .............................................................................................................................37
SC-AP OptiView Mounting ............................................................................................................................37
Using the SC-AP for Troubleshooting.............................................................................................................39
E-Link Replacement .......................................................................................................................................40
Manually Setting the Chiller Model ................................................................................................................. 41
SECTION 5 - TECHNICAL SPECIFICATIONS .......................................................................................................43
SECTION 6 - LON PROTONODE ...........................................................................................................................45
Overview ........................................................................................................................................................45
Installation ......................................................................................................................................................46
ProtoNode LED Functionality .........................................................................................................................49
Binding the Points Using the .XIF File ............................................................................................................ 49
Technical Specifications .................................................................................................................................50