Kohler KDW 2204 - California Emission Control Warranty Statement; Your Warranty Rights And Obligations

2
- 13 - - 13 -
General remarks and safety information
CAUTION
DANGER
Electrical Shock can cause
injury.
Donot touch wireswhileengineis
running.
Electrical Shock!
Never touch electrical wires or
components while the engine is
running. They can be sources of
electrical shock.
California Proposition 65
WARNING
Engine exhaust from this product contains
chemicals known to the State of California to cause
cancer, birth defects, or other reproductive harm.
High Pressure Fluids can
puncture skin and cause severe
injury or death.
Do not work on fuel system without
propertrainingorsafetyequipment.
H i g h P r e s s u r e F l u i d
Puncture!
Fuel system is to be serviced only by
properly trained personnel wearing
protective safety equipment. Fluid
puncture injuries are highly toxic and
hazardous. If an injury occurs, seek
immediate medical attention.
Workshop Manual KDW 1603_2204_2204/T _ cod. ED0053029180 - 1° ed_rev. 00
CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT
YOUR WARRANTY RIGHTS AND OBLIGATIONS
The California Air Resources Board andKohlerCo.arepleasedtoexplaintheemission control system warrantyonyour2012engine.In
California,newheavy-dutyoff-roadenginesmustbedesigned,builtandequippedtomeettheState’sstringentanti-smogstandards.KohlerCo.
mustwarranttheemissioncontrolsystemonyourengineforthetimeperiodlistedbelowprovidedtherehasbeennoabuse,neglectorimproper
maintenanceofyourengine.
Youremission controlsystemmayinclude partssuchasthe fuel-injectionsystemandthe airinductionsystem.Alsoincluded may behoses,
connectorsandotheremissionrelatedassemblies.
Whereawarrantableconditionexists,KohlerCo.willrepairyourheavy-dutyoff-roadengineatnocosttoyouincludingdiagnosis,partsandlabor.
MANUFACTURER’S WARRANTY COVERAGE:
Youroff-road,dieselengineemissioncontrolsystemiscoveredunderwarrantyforaperiodofve(5)yearsor3,000hours,whicheveroccursrst,
beginningonthedatetheengineorequipmentisdeliveredtoanultimatepurchaserforallconstantspeedengineswithmaximumpower19≤kW<37
andratedspeedlessthan3,000rpm,allvariablespeedengineswithmaximumpower19≤kW<37,andallvariableorconstantspeedengineswith
maximumpowergreaterthan37kW.Youroff-road,dieselengineemissioncontrolsystemonvariableorconstant-speedengineswithmaximum
powerlessthan19kW,andforconstantspeedengineswithmaximumpower19≤kW<37andratedspeedequaltoorgreaterthan3,000rpmis
coveredunderwarrantyforaperiodoftwo(2)yearsor1,500hours,whichever
occursrst.Ifanyemissionrelatedpartonyourengineisdefective,thepartwillberepairedorreplacedbyKohlerCo.
OWNER’S WARRANTY RESPONSIBILITIES:
Asthe heavy-duty off-road engine owner, you are responsiblefor theperformance ofthe required maintenance listed in your Kohler Co.
owner’s manual.KohlerCo.recommendsthatyouretainallreceiptscoveringmaintenanceonyourheavy-dutyoff-roadengine,butKohlerCo.
cannotdenywarrantysolelyforthelackofreceiptsorforyourfailuretoensuretheperformanceofallrecommendedscheduledmaintenance.
Astheheavy-dutyoff-roadengineowner,youshouldhoweverbeawarethatKohlerCo.maydenyyouwarrantycoverageifyourheavy-dutyoff-
roadengineoremissioncontrolrelatedcomponenthasfailedduetoabuse,neglect,impropermaintenanceorunapprovedmodications.
Yourengineisdesignedtooperateoncommercialdieselfuel(No.1orNo.2lowsulfurorultralowsulfurdieselfuel)only.Useofanyotherfuel
mayresultinyourenginenolongeroperatingincompliancewithCalifornia’semissionsrequirements.
Youareresponsibleforinitiatingthewarrantyprocess.TheAirResourcesBoardsuggeststhatyoupresentyourheavy-dutyoff-roadenginetoa
KohlerCo.dealerassoonasaproblemexists.Thewarrantyrepairsshouldbecompletedbythedealerasexpeditiouslyaspossible.
Pleasereviewthedocumenttitled,“KohlerCo.FederalandCaliforniaEmissionControlSystemsLimitedWarrantyOff-RoadDieselEngines”,for
completedetailsofyourheavy-dutyoff-roadenginewarranty.Ifyouhaveanyquestionsregardingyourwarrantyrightsandresponsibilitiesorthe
locationofthenearestKohlerCo.authorizedservicelocation,youshouldcontactKohlerCo.at1-800-544-2444oraccessourwebsiteatwww.
kohlerengines.com.