Kubota LX2610 - Safe Operation Guidelines; Pre-Operation Checks and Precautions; CAB and ROPS Safety Considerations

To Next Page

To Previous Page

INDEX.......................................................................................................................................147

LX2610,LX3310

Main Page

Table of Contents6
Safe Operation13
Servicing of Tractor29
Warranty30
Scrapping the Tractor and Its Procedure30
Specifications31
Specification Table for Rops Model31
Specification Table for Cab Model33
Traveling Speeds35
Implement Limitations37
Implement Specification Table38
Instrument Panel and Controls39
Switches and Hand Controls39
Instrument Panel41
Foot and Hand Controls for Rops Model42
Pre-Operation Check44
Daily Check44
Operating the Engine45
Exhaust Aftertreatment Devices [Lx3310 Only]45
Diesel Particulate Filter (Dpf) Muffler45
Handling Points45
DPF Regeneration Process46
Operating Procedure for Auto Regeneration Mode47
PM Warning Level and Required Procedures48
Operating Procedure for Regeneration Inhibit Mode49
PM Warning Level and Required Procedures50
Operating Procedure for Parked Regeneration51
Tips on Diesel Particulate Filter (DPF) Regeneration52
Starting the Engine52
Operating the Engine in Freezing Conditions57
Block Heater (if Equipped)57
Stopping the Engine57
Warming up the Engine57
Warm-Up and Transmission Fluid at Low Temperature Range57
Jump Starting57
Operating the Tractor59
Operating New Tractor59
Do Not Operate the Tractor at Full Speed for the First 50 Hours59
Changing Lubricating Oil for New Tractors59
Boarding and Leaving the Tractor59
Operating Foldable Rops (if Equipped)59
Folding the ROPS59
Raising the ROPS to Upright Position60
Adjustment of Foldable ROPS60
Starting the Tractor61
Operator's Seat61
Seat Belt62
Tilt Steering Adjustment [Except LX2610SU]62
Headlight Switch63
Turn Signal Switch and Hazard Light Switch63
Horn Button [CAB Only]64
Brake Pedals (Right and Left)64
Parking Brake Lever65
Range Gear Shift Lever (L-M-H)65
Front Wheel Drive Lever66
Front-Wheel Drive (4WD) Usage66
Hand Throttle Lever67
Speed Control Pedal67
Speed Set Lever [LX2610/LX3310 ROPS Model]67
Cruise Control Lever [LX2610/LX3310 CAB Model]68
Stopping the Tractor69
Check During Driving69
Fuel Temperature Indication69
Engine Low Temperature Regulation69
Easy Checker69
Fuel Gauge70
Coolant Temperature Gauge70
Hourmeter and Tachometer71
Changing Display Mode71
Parking the Tractor72
Operating Techniques72
Differential Lock72
Operating the Tractor on a Road73
Operating on Slopes and Rough Terrain74
Transporting the Tractor Safely74
Directions for the Use of Power Steering74
Electrical Outlet74
Pto76
Pto Operation76
PTO Select Lever [Except LX2610SU]76
PTO Clutch Lever [LX2610/LX3310]77
PTO Clutch Lever [LX2610SU]77
LCD Monitor Message78
PTO Shaft Cover and Shaft Cap78
Stationary PTO79
3-Point Hitch and Drawbar80
The 3-Point Hitch Setup82
Selecting the Holes of Lower Links82
Selecting the Top Link Mounting Holes82
Drawbar83
Lifting Rod (Right)83
Top Link83
Telescopic Stabilizers83
Telescopic Lower Links [CAB Model]84
Drawbar84
Adjusting Drawbar Length84
Hydraulic Unit85
3-Point Hitch Control System85
Position Control85
Point Hitch Lowering Speed Knob85
Auxiliary Hydraulics86
Hydraulic Block Type Outlet86
Dual Remote Hydraulic Control System86
Control Lever and Hydraulic Hose Connections86
Rear Hydraulic Outlet (if Equipped)87
Loader/Remote Control Valve Lever88
Valve Lock88
Remote Hydraulic Control System (if Equipped)88
Remote Control Valve89
Remote Control Valve Lever89
Remote Control Valve Coupler90
Hydraulic Control Unit Use-Reference Chart91
Tires, Wheels and Ballast92
Tires92
Inflation Pressure92
Dual Tires92
Wheel Adjustment92
Front Wheels92
Front Jack Point93
Rear Wheels93
Rear Jack Point93
Treads94
Ballast95
Front Ballast95
Front End Weights (Option)95
Rear Ballast95
Liquid Ballast in Rear Tires95
Cab Operation97
Doors and Windows97
Locking and Unlocking the Door97
Opening the Door97
Rear Window97
Rear Window Half-Lock97
Emergency Exit98
Light98
Dome Light98
Work Light Switch98
Front Work Light99
Rear Work Light (if Equipped)99
Wiper99
Front Wiper and Washer Switch99
Rear Wiper and Washer Switch99
Using the Wipers in Cold Season99
Air Conditioner100
Airflow100
Air Control Vent100
Front Air Outlet100
Side Air Outlet and Door Air Outlet100
Recirculation or Fresh Air Selection Lever101
Control Panel101
Mode Switch101
Temperature Control Dial101
Blower Switch101
Air Conditioner Switch101
Operation102
Heating102
Cooling or Dehumidifying-Heating102
Foot Warming and Head Cooling102
Defrosting or Demisting103
Rear Defogger103
Hanger104
Maintenance105
Service Intervals105
Lubricants, Fuel and Coolant108
Biodiesel Fuel (BDF) B0-B20110
Periodic Service112
Waste Disposal112
How to Open the Hood112
Hood112
Open the Hood112
Close the Hood113
Engine Side Cover113
Daily Check113
Walk Around Inspection113
Checking and Refueling113
Checking Water Separator [LX3310]114
Checking Engine Oil Level114
Checking Transmission Fluid Level115
Checking Coolant Level115
Cleaning Evacuator Valve116
Cleaning Air Conditioner Condenser Screen (CAB Model)116
Cleaning Grill and Radiator Screen117
Checking DPF Muffler [LX3310]117
Checking Brake Pedal117
Checking Gauges, Meter and Easy Checker118
Checking Headlight, Hazard Light, and so on118
Checking Seat Belt and ROPS118
Checking and Cleaning of Electrical Wiring and Battery Cables118
Checking Movable Parts118
Every 50 Hours118
Lubricating Grease Fittings118
Checking Engine Start System119
Checking Wheel Bolt Torque120
Every 100 Hours120
Checking Battery Condition120
How to Read Indicator121
Charging the Battery121
Directions for Battery Storage121
Cleaning Air Cleaner Primary Element122
Cleaning Fuel Filter [LX2610/LX2610SU]123
Adjusting Fan Belt Tension123
Adjusting Brake Pedal124
Every 200 Hours124
Replacing Engine Oil Filter124
Changing Engine Oil125
Replacing Transmission Oil Filter125
Checking Power Steering Line126
Adjusting Toe-In127
Adjusting Air Conditioner Belt Tension (CAB Model)127
Cleaning Inner Air Filter (CAB Model)127
Cleaning Fresh Air Filter (CAB Model)128
Cleaning the Filter128
Checking the Air Conditioner Condenser (CAB Model)128
Every 400 Hours129
Replacing Water Separator [LX3310]129
Changing Transmission Fluid129
Replacing Hydraulic Oil Filter130
Replacing Fuel Filter [LX3310]131
Replacing Fuel Filter [LX2610/LX2610SU]131
Adjusting Front Axle Pivot (4WD)132
Changing Front Axle Gear Case Oil132
Every 800 Hours133
Adjusting Engine Valve Clearance133
Every 1000 Hours or 1 Year133
Replacing Air Cleaner Primary Element and Secondary Element133
Every 1500 Hours133
Cleaning Fuel Injector Nozzle Injection Pressure133
Checking EGR Cooler [LX3310]133
Every 2000 Hours or 2 Years133
Flushing Cooling System and Changing Coolant133
Antifreeze134
Every 3000 Hours135
Checking Injection Pump [LX2610/LX2610SU]135
Checking EGR System [LX3310]135
Checking Supply Pump [LX3310]135
Cleaning DPF Muffler [LX3310]135
Checking Turbocharger [LX3310]135
Every 1 Year135
Checking Exhaust Manifold [LX3310]135
Checking the Radiator Hoses and Clamps135
Overheating Countermeasures136
Checking Fuel Lines136
Checking Intake Air Line136
Checking the Air Conditioner Pipe and Hose (CAB Model)137
Checking CAB Isolation Cushion (CAB Model)137
Every 4 Years137
Replacing Radiator Hose (Water Pipes)137
Replacing Power Steering Line137
Replacing Fuel Lines137
Replacing Intake Air Line137
Replacing Differential Pressure Sensor Hose [LX3310]137
Replacing Air Conditioner Hose (CAB Model)138
Service as Required138
Bleeding Fuel System138
Draining Clutch Housing Water138
Replacing Fuses138
Replacing Light Bulb141
Replacing Headlamp142
Lubricating Points for Door and Window (CAB Model)142
Adding Washer Liquid (CAB Model)142
Checking Amount of Refrigerant (Gas) (CAB Model)142
Replacing Radiator Hose (Water Pipes)143
Replacing Fuel Lines143
Replacing the Intake Air Line143
Storage144
Tractor Storage144
Removing the Tractor from Storage144
Troubleshooting145
Engine Troubleshooting145
Powertrain Trouble Shooting146
Options147
List of Options147
Mounting the Support Plate147
Installation Procedures147

Kubota LX2610 - Safe Operation Guidelines; Pre-Operation Checks and Precautions; CAB and ROPS Safety Considerations

Table of Contents

Related product manuals