Lenovo HR630X V2 - Default Chapter; Table of Contents

Contents
Safety . . . . . . . . . . . . . . . . . . . iii
Safety inspection checklist . . . . . . . . . . . iv
Security advisories . . . . . . . . . . . . . . v
Chapter 1. Introduction . . . . . . . . . 1
Specifications . . . . . . . . . . . . . . . . 1
Chapter 2. Server components . . . . . 5
Front view . . . . . . . . . . . . . . . . . . 5
Rear view . . . . . . . . . . . . . . . . . 12
System board . . . . . . . . . . . . . . . 20
Parts list. . . . . . . . . . . . . . . . . . 21
Chapter 3. Server hardware setup . . 25
Server setup procedure. . . . . . . . . . . . 25
Power on the server . . . . . . . . . . . . . 25
Power off the server . . . . . . . . . . . . . 25
Chapter 4. Hardware replacement
procedures . . . . . . . . . . . . . . . 27
Installation Guidelines . . . . . . . . . . . . 27
System reliability guidelines . . . . . . . . 28
Handling static-sensitive devices . . . . . . 28
Air baffle replacement . . . . . . . . . . . . 29
Remove the air baffle . . . . . . . . . . . 29
Install the air baffle . . . . . . . . . . . . 30
CMOS battery replacement . . . . . . . . . . 31
Remove the CMOS battery . . . . . . . . 31
Install the CMOS battery . . . . . . . . . 33
Front I/O assembly replacement . . . . . . . . 35
Remove the front I/O assembly . . . . . . . 35
Install the front I/O assembly . . . . . . . . 36
Hot-swap drive replacement . . . . . . . . . . 37
Remove a hot-swap drive . . . . . . . . . 37
Install a hot-swap drive . . . . . . . . . . 38
Backplane replacement. . . . . . . . . . . . 40
Remove the front 2.5-inch-drive backplane . . 40
Install the front 2.5-inch-drive backplane . . . 41
Remove the front 3.5-inch-drive backplane . . 42
Install the front 3.5-inch-drive backplane . . . 43
Remove the 2.5-inch rear drive backplane. . . 44
Install the 2.5-inch rear drive backplane . . . 46
Hot-swap rear drive assembly replacement . . . . 48
Remove the hot-swap rear drive assembly . . 48
Install the hot-swap rear drive assembly . . . 49
Hot–swap power supply unit replacement . . . . 51
Safety precautions . . . . . . . . . . . . 51
Remove a hot-swap power supply unit . . . . 54
Install a hot-swap power supply unit . . . . . 55
Memory module replacement . . . . . . . . . 57
Remove a memory module . . . . . . . . 57
Memory module installation rules . . . . . . 58
Install a memory module . . . . . . . . . 59
M.2 adapter and M.2 drive replacement . . . . . 61
Remove the M.2 adapter and M.2 drive. . . . 62
Adjust the retainer on the M.2 adapter . . . . 64
Install the M.2 adapter and M.2 drive. . . . . 65
OCP 3.0 Ethernet adapter replacement . . . . . 67
Remove the OCP 3.0 Ethernet adapter . . . . 67
Install the OCP 3.0 Ethernet adapter . . . . . 68
PCIe adapter replacement. . . . . . . . . . . 70
Remove a PCIe adapter . . . . . . . . . . 71
Install a PCIe adapter . . . . . . . . . . . 72
Processor and heat sink replacement . . . . . . 73
Remove a standard heat sink. . . . . . . . 73
Remove a T-shaped heat sink . . . . . . . 74
Remove a processor . . . . . . . . . . . 75
Install a processor . . . . . . . . . . . . 76
Install a standard heat sink. . . . . . . . . 77
Install a T-shaped heat sink . . . . . . . . 79
Rack latches replacement. . . . . . . . . . . 80
Remove the rack latches . . . . . . . . . 80
Install the rack latches . . . . . . . . . . 82
RAID super capacitor module replacement . . . . 84
Remove the RAID super capacitor module on
the chassis . . . . . . . . . . . . . . . 85
Install the RAID super capacitor module on
the chassis . . . . . . . . . . . . . . . 87
Remove the RAID super capacitor module on
the air baffle . . . . . . . . . . . . . . 89
Install the RAID super capacitor module on
the air baffle . . . . . . . . . . . . . . 90
Remove the RAID super capacitor module on
the riser . . . . . . . . . . . . . . . . 90
Install the RAID super capacitor module on
the riser . . . . . . . . . . . . . . . . 91
Riser card replacement . . . . . . . . . . . . 92
Remove a riser card . . . . . . . . . . . 92
Install a riser card . . . . . . . . . . . . 95
System fan replacement . . . . . . . . . . . 97
Remove a system fan. . . . . . . . . . . 97
Install a system fan. . . . . . . . . . . . 98
Fan board replacement . . . . . . . . . . . . 100
Remove the fan board . . . . . . . . . . 100
Install the fan board . . . . . . . . . . . 101
System board replacement . . . . . . . . . . 102
© Copyright Lenovo 2021 i