To Next Page

To Previous Page

3 -1

Clutch pedal

Light switch

Turn signal

light switch

Hazard warning

light indicator

Horn switch

Grille work

light switch

Shuttle lever

(optional)

DPF switch

Key switch

Brake pedals

Throttle pedal

Instrument panel

Important to owner, read carefully

Throttle lever

PTO switch

PTO mode switch

(if fitted)

Creeper gear lever

(if fitted)

Tilt lever

(See page 2-8)

Mechanical type

3. Instruments and Controls

3-1. Instrument panel and Front controls

 Depending on the optional specifications, some figures may be different from your tractor.

Table of Contents9
General Notices for Safety15
Note to the Owner - General Information15
Before Using the Tractor17
Manual Scope and Required Training Level19
Metric and Imperial Units Abbreviations21
Product Identification Number (PIN)23
Operator's Manual Storage25
Tractor Orientation26
Safety Precautions (Read this for Safety before Using)27
Notices before Using the Tractor27
Notices When Starting Engine31
Notices While Operating/Using the Tractor32
Notices When Connecting Implement34
Notices When Towing the Tractor35
Notices When Transporting the Tractor35
Notices When Servicing the Tractor after Work36
Notices When Handling Diesel Fuel37
Notices When Leaving the Tractor38
Notices Relating to Toxic Substances38
Tractor Stability39
Ecology and the Environment42
Symbols44
Safety Decals45
Instructional Decals54
Long-Term Storage59
Preparation for Storage59
Check & Maintenance During Storage60
Preparation for Reuse61
Instruction for Safe Operation63
The Name of each Part63
Boarding and Exiting the Tractor65
Boarding the Tractor65
Driver's Seat (HST Type)66
Seat Adjustment67
Seat Belt69
Tilting Steering Wheel70
Ventilation (Cabin Only)70
Exiting the Tractor71
Safety Device72
Hood (Bonnet)72
Fender72
PTO Safety Cover and Protection Cap72
Roll-Over Protective Structure (ROPS)73
Instruments and Controls77
Instrument Panel and Front Controls77
Instrument Panel79
Key Switch86
Turn Signal Light Switch87
Light Switch88
Hazard Warning Light Switch89
Horn Switch90
Grille Work Light Switch90
DPF Switch91
PTO Switch96
PTO Mode Switch96
Shuttle Lever (Mechanical)97
Throttle Lever98
Throttle Pedal (Mechanical)99
Clutch Pedal (Mechanical)99
Brake Pedals100
Cruise Control Switch (HST Type)101
HST Forward/Reverse Pedal (HST Type)101
Creeper Gear Lever (Mechanical, if Fitted)102
HST Linked Pedal Switch (HST Type, Optional)103
ESC Main Switch (Roll-Bar, HST Models Only)104
ESC Speed Up/Down Switch (Roll-Bar, HST Models Only)104
Right-Hand Controls and Cabin Pillar (Cabin Type)105
Main Gear Shift Lever (Mechanical)105
Clutch Button (MPC Models Only)106
Range Gear Shift Lever (HST Type)107
Parking Brake Lever108
Differential Lock Pedal108
Work Light Switch109
Window Wiper&Washer Switch (Front, Rear)109
Electrical Power Outlet Socket (Cabin Only)110
Indoor Light (Cabin Only)110
Audio Player (Cabin Only) (if Fitted)110
ESC Main Switch111
ESC Speed Up/Down Switch111
Beacon Lamp Switch112
Left-Hand Controls (Cabin Type)113
Range Gear Shift Lever (Mechanical)114
PTO Gear Lever (if Fitted)114
Four Wheel Drive Lever (4WD)115
Middle PTO Lever (if Fitted)115
Ground Speed PTO(GSP) Lever (if Fitted)116
Clutch Engaging Speed Adjustment Knob (MPC Models Only)116
Left / Right-Hand Controls (Roll-Bar Type)117
Main Gear Shift Lever (Mechanical)117
Clutch Button (MPC Models Only)118
Range Gear Shift Lever (HST Type)119
Parking Brake Lever120
Differential Lock Pedal120
ESC Main Switch (MEC, MPC Models Only)121
ESC Speed Up/Down Switch (MEC, MPC Models Only)121
Work Light Switch122
Range Gear Shift Lever (Mechanical)122
PTO Gear Lever (if Fitted)123
Four Wheel Drive Lever (4WD)123
Middle PTO Lever (if Fitted)124
Ground Speed PTO(GSP) Lever (if Fitted)124
Clutch Engaging Speed Adjustment Knob (MPC Models Only)125
Hydraulic System126
Safety Precautions126
Steering System127
Hydraulic Lift Control (MHL) (Cabin Type)127
Hydraulic Lift Control (MHL) (Roll-Bar Type)129
Remote Control Lever and Quick Coupler (Optional)132
Joystick Lever (if Fitted)134
Hydraulic System Diagram135
Operation and Work139
How to Handle New Tractor139
Check Points139
Notices in Handling New Tractor (Engine Brake-In Procedure)139
Engine Start and Stop140
Engine Start140
Start in Cold Weather142
Engine Stop143
How to Drive and Stop144
Transmission Warm-Up in Cold Weather144
How to Drive145
Changing Speed147
Emergency Stop148
Stopping Tractor149
Parking150
Handling Turbocharger (if Fitted)150
Transport on Public Roads151
Safety Rules When Driving Tractor on the Roads151
Light Operation152
7-Pole Connector (Optional)154
Notices When Towing the Tractor155
Notices When Transporting the Tractor157
Field Operations158
Rear 3-Point Linkage158
Power Take-Off (PTO) Operation162
Hitch and Drawbar (Optional)165
Technically Maximum Permissible Mass166
Tires and Load Capacity167
Adjusting Wheel Tracks and Tire Replacement168
Using Front-End Loader (if Fitted)169
Adjusting Steering Angle172
Recommended Maximum Specification of Implements173
Ballasting Weights (Optional)174
Working in Hazardous Area177
Driving Speed178
Lubrication and Maintenance181
General Information181
Tightening Torque for Normal Assembly182
Standard Torque Data for Hydraulics184
General Specification - Diesel Fuel187
Biodiesel Fuel188
Refueling the Tractor190
Change Engine Coolant to Organic Acid Technology (OAT) Coolant191
Access for Maintenance192
Maintenance Chart193
Lubricants and Capacity197
First 50 Hour Check198
When the Warning Indicator Lights199
Check before Starting (Daily Check)201
Engine Oil201
Fuel Tank202
Instrument Panel & Indicators202
Turn Signal Lights, Lights and Horn203
Engine Coolant204
Air Cleaner (Dry Type)204
Cleaning of Radiator and Radiator Screen205
Tire Air Pressure & Damage205
Tightening State of Bolts and Nuts of each Part206
Adjustment of Clutch Pedal Play (Mechanical Type)207
Adjustment of Brake Pedal Play209
Adjusting HST Control Linkage (HST Type)210
Every 50 Hour Check212
Lubricating Grease Nipple212
Cleaning of Radiator and Radiator Screen212
Checking Transmission Oil213
Checking Front Axle Oil213
Battery Check213
Air Cleaner (Dry Type)213
Hydraulic Hoses and Leakage214
Cleaning Cabin Air Filters214
Every 100 Hour Check215
Checking and Adding Engine Oil215
Every 300 Hour Check216
Replacing Engine Oil and Filter216
Replacing Hydraulic Oil Filter217
Tension Adjustment of Engine Belt218
Toe-In218
Cleaning Fuel Tank219
Every 500 Hour Check220
Replacing Fuel Filter Element220
Replacing Air Cleaner Element (Dry Type)221
Replacing Cabin Air Filters221
Every 600 Hour Check222
Changing Front Axle Oil222
Changing Transmission Oil222
Every 1000Hr or 1-Year Check223
Adjusting Engine Valve Clearance223
Checking Nozzle Injection Pressure223
Every 1500Hr or 2-Year Check224
Replacement of Engine Coolant224
Cleaning Emission Related Parts227
Every 3000Hr Check228
Cleaning Emission Related Parts228
General Maintenance (When Required)229
Air-Bleeding from Fuel System229
Fuse & Main Fuse231
Battery Handling and Notices233
Alternator and Drive Belt - Check237
Tail/Brake Light Bulb and Turn Signal Light Bulb- Replace238
Headlight Bulb - Replace240
Touch-Up Paint Color241
Troubleshooting242
Air Conditioning System (Cabin Type)249
The Name of each Part of Cooling and Heating System249
How to Use Air Conditioner and Heater250
How to Operate Air Conditioner and Heater250
Air Direction Control250
Every 6 Month Check251
Checking Refrigerant Amount251
Cleaning Condenser and Radiator Screen251
Checking Leakage251
Belt Tension Adjustment252
Cleaning and Replacing Cabin Air Filters252
Every Year Check253
Compressor Check253
Control Switch Check253
Troubleshooting254
System Diagram256

Brand	LS tractor
Model	MT342
Category	Tractor
Language	English

LS tractor MT342 User Manual

Table of Contents

Questions and Answers:

LS tractor MT342 Specifications

Related product manuals