LS tractor XR4150

To Next Page

To Previous Page

7 -2

(Unit : mm)

② Roll-bar type

* Front tires : 9.5-16 6PR / Rear tires : 13.6-24 8PR

Main Page

Table of Contents9
General Notices for Safety15
Note to the Owner - General Information15
Before Using the Tractor17
Manual Scope and Required Training Level19
Metric and Imperial Units Abbreviations21
Product Identification Number (PIN)23
Operator's Manual Storage25
Tractor Orientation26
Safety Precautions (Read this for Safety before Using)27
Notices before Using the Tractor27
Notices When Starting Engine31
Notices While Operating/Using the Tractor32
Notices When Connecting Implement34
Notices When Towing the Tractor35
Notices When Transporting the Tractor35
Notices When Servicing the Tractor after Work36
Notices When Handling Diesel Fuel37
Notices When Leaving the Tractor38
Notices Relating to Toxic Substances38
Tractor Stability39
Ecology and the Environment42
Symbols44
Safety Decals45
Instructional Decals54
Long-Term Storage59
Preparation for Storage59
Check & Maintenance During Storage60
Preparation for Reuse61
Instruction for Safe Operation63
The Name of each Part63
Boarding and Exiting the Tractor65
Boarding the Tractor65
Driver's Seat (HST Type)66
Seat Adjustment67
Seat Belt69
Tilting Steering Wheel70
Ventilation (Cabin Only)70
Exiting the Tractor71
Safety Device72
Hood (Bonnet)72
Fender72
PTO Safety Cover and Protection Cap72
Roll-Over Protective Structure (ROPS)73
Instruments and Controls77
Instrument Panel and Front Controls77
Instrument Panel79
Key Switch85
Turn Signal Light Switch86
Light Switch87
Hazard Warning Light Switch88
Horn Switch89
Grille Work Light Switch89
DPF Switch90
PTO Switch95
PTO Mode Switch95
Shuttle Lever (Mechanical Synchro-Shuttle)96
Throttle Lever96
Throttle Pedal (Mechanical)97
Clutch Pedal (Mechanical)97
Brake Pedals98
Cruise Control Switch (HST Type)99
HST Forward/Reverse Pedal (HST Type)99
Creeper Gear Lever (MEC, if Fitted)100
Right-Hand Controls and Cabin Pillar (Cabin Type)101
Main Gear Shift Lever (Mechanical)101
Range Gear Shift Lever (HST Type)102
Parking Brake Lever103
Differential Lock Pedal103
Work Light Switch104
Window Wiper Switch (Front, Rear)104
Electrical Power Outlet Socket (Cabin Only)105
Indoor Light (Cabin Only)105
Audio Player (Cabin Only) (if Fitted)105
ESC Main Switch106
ESC Speed Up/Down Switch106
Beacon Lamp Switch107
Left-Hand Controls (Cabin Type)108
Range Gear Shift Lever (Mechanical)109
PTO Gear Lever (if Fitted)109
Four Wheel Drive Lever (4WD)110
Middle PTO Lever (if Fitted)110
Ground Speed PTO(GSP) Lever (if Fitted)111
Left / Right-Hand Controls (Roll-Bar Type)112
Main Gear Shift Lever (Mechanical)112
Range Gear Shift Lever (HST Type)113
Parking Brake Lever114
Differential Lock Pedal114
ESC Main Switch115
ESC Speed Up/Down Switch115
Work Light Switch116
Range Gear Shift Lever (Mechanical Only)116
PTO Gear Lever (if Fitted)117
Four Wheel Drive Lever (4WD)117
Middle PTO Lever (if Fitted)118
Ground Speed PTO(GSP) Lever (if Fitted)118
Hydraulic System119
Safety Precautions119
Steering System120
Hydraulic Lift Control (MHL) (Cabin Type)120
Hydraulic Lift Control (MHL) (Roll-Bar Type)122
Remote Control Lever and Quick Coupler (Optional)125
Joystick Lever (if Fitted)127
Hydraulic System Diagram128
Operation and Work131
How to Handle New Tractor131
Check Points131
Notices in Handling New Tractor (Engine Brake-In Procedure)131
Engine Start and Stop132
Engine Start132
Start in Cold Weather134
Engine Stop135
How to Drive and Stop136
Transmission Warm-Up in Cold Weather136
How to Drive137
Changing Speed139
Emergency Stop140
Stopping Tractor141
Parking142
Handling Turbocharger (if Fitted)142
Transport on Public Roads143
Safety Rules When Driving Tractor on the Roads143
Light Operation144
7-Pole Connector (Optional)146
Notices When Towing the Tractor147
Notices When Transporting the Tractor149
Field Operations150
Rear 3-Point Linkage150
Power Take-Off (PTO) Operation154
Hitch and Drawbar (Optional)157
Technically Maximum Permissible Mass158
Tires and Load Capacity159
Adjusting Wheel Tracks and Tire Replacement160
Using Front-End Loader (if Fitted)161
Adjusting Steering Angle164
Recommended Maximum Specification of Implements165
Ballasting Weights (Optional)166
Working in Hazardous Area169
Driving Speed170
Lubrication and Maintenance173
General Information173
Tightening Torque for Normal Assembly174
Standard Torque Data for Hydraulics176
General Specification - Diesel Fuel179
Biodiesel Fuel180
Refueling the Tractor182
Change Engine Coolant to Organic Acid Technology (OAT) Coolant183
Access for Maintenance184
Maintenance Chart185
Lubricants and Capacity189
First 50 Hour Check190
When the Warning Indicator Lights191
Drain Water from Fuel Filter191
Engine Oil Pressure Indicator192
Battery Charging Indicator192
Check before Starting (Daily Check)193
Engine Oil193
Fuel Tank194
Instrument Panel & Indicators194
Turn Signal Lights, Lights and Horn195
Engine Coolant196
Air Cleaner (Dry Type)196
Cleaning of Radiator and Radiator Screen197
Tire Air Pressure & Damage197
Tightening State of Bolts and Nuts of each Part198
Adjustment of Clutch Pedal Play (Mechanical Type)199
Adjustment of Brake Pedal Play200
Adjusting HST Control Linkage (HST Type)201
Every 50 Hour Check202
Lubricating Grease Nipple202
Cleaning of Radiator and Radiator Screen202
Checking Transmission Oil203
Checking Front Axle Oil203
Battery Check203
Air Cleaner (Dry Type)203
Hydraulic Hoses and Leakage204
Cleaning Cabin Air Filters204
Every 100 Hour Check205
Checking and Adding Engine Oil205
Every 300 Hour Check206
Replacing Engine Oil and Filter206
Replacing Hydraulic Oil Filter207
Tension Adjustment of Engine Belt208
Toe-In208
Cleaning Fuel Tank208
Every 500 Hour Check209
Changing Front Axle Oil209
Changing Transmission Oil209
Replacing Fuel Filter Cartridge210
Replacing Air Cleaner Element (Dry Type)210
Replacing Cabin Air Filters211
Every 1000Hr or 1-Year Check212
Adjusting Engine Valve Clearance212
Checking Nozzle Injection Pressure212
Every 1500Hr or 2-Year Check213
Replacement of Engine Coolant213
Cleaning Emission Related Parts216
Every 3000Hr Check217
Cleaning Emission Related Parts217
General Maintenance (When Required)218
Air-Bleeding from Fuel System218
Fuse & Main Fuse220
Battery Handling and Notices222
Alternator and Drive Belt - Check226
Tail/Brake Light Bulb and Turn Signal Light Bulb- Replace227
Headlight Bulb - Replace229
Touch-Up Paint Color230
Troubleshooting231
Air Conditioning System (Cabin Type)237
The Name of each Part of Cooling and Heating System237
How to Use Air Conditioner and Heater238
How to Operate Air Conditioner and Heater238
Air Direction Control238
Every 6 Month Check239
Checking Refrigerant Amount239
Cleaning Condenser and Radiator Screen239
Checking Leakage239
Belt Tension Adjustment240
Cleaning and Replacing Cabin Air Filters240
Every Year Check241
Compressor Check241
Control Switch Check241
Troubleshooting242
System Diagram244

LS tractor XR4150 - Page 246

Table of Contents

Related product manuals