Page 92
MAINTENANCE
CENTRI-MAX
®
FILTER REPLACEMENT
(Externally Drained Filter)
1. Clean the area around the centrifugal filter
before removing the drain hose.
2. Loosen the hose clamp at the bottom of the
filter housing and disconnect the drain hose.
3. Loosen the hose clamp at the cylinder block
drain and rotate the hose out of the way.
4. Using tool J 24783, remove the centrifugal
oil filter housing.
Be sure to apply the filter removal tool on the filter
housing at the point marked “WRENCH HERE.”
5. Remove and discard the filter seal and rotor.
Clean the filter housing.
6. Install a new filter seal and rotor in the filter
housing.
7. Apply a thin film of engine oil to the sealing
gasket. Install the centrifugal filter housing
and tighten the housing an additional 3/4 turn
BY HAND after the gasket contacts the base.
8. Install the drain hose on the base of the filter
housing and tighten the hose clamps at the
cylinder block and filter housing.
9. Start the engine and check for leaks.
CENTRI-MAX
®
PLUS FILTER REPLACEMENT
(Internally Drained Filter)
1. To prevent contamination from entering the
engine, thoroughly clean the area around
the centrifugal oil filter (Figure 72) before
removing the cover assembly.
2. Loosen the nut at the top of the cover
assembly, then remove the cover.
3. Remove and discard the rotor.
4. Clean the inside of the cover assembly.
5. Install a new rotor over the spindle.
Use only the rotor designed for use with the
Centri-Max
®
PLUS centrifugal filter assembly.
Any other rotor will not work.
6. Remove and discard the seal from the cover
assembly.
7. Install a new seal.
8. Apply a thin film of clean engine oil to the seal.
9. Install the cover assembly.
10. Tighten the cover assembly nut to 15 lb-ft
(20 N•m).
11. Start the engine and check for leaks.
72
Figure 72 — Centri-Max
®
PLUS Oil Filter Assembly
1. Cover Bolt
2. Centri-Max
®
PLUS Cover Assembly
3. Centri-Max
®
PLUS Rotor (Part No. 236GB245M)
4. O-Ring
5_106_00.bk Page 92 Friday, August 4, 2000 11:17 AM
BDC for engine manuals and specs
https://barringtondieselclub.co.za/
To Next Page
Loading...
