Mahindra USA, Inc. All Rights Reserved.
9-1
9 Prepare to Ride
Before a ride, the operator should always perform a Pre-Ride
Inspection to confirm the safe operating condition of the ROXOR.
Refer to section 9.1 Pre-Ride Inspection Checklist. Operator and
passengers must be properly seated, with both side nets latched
and doors closed (if equipped) and seat belts fastened. Wear the
appropriate riding gear. Refer to section 8 Riding Gear for more
information.
Perform a Pre-Ride Inspection before each ride to help detect any
potential problems that could occur during operation. The Pre-
Ride Inspection can help you monitor component wear and
deterioration before they become a problem. Correct any problem
that you discover to help reduce the risk of a breakdown or
accident.
Always follow the maintenance schedule described in this
Operator’s Guide to also keep your vehicle in safe working order.
9.1 Pre-Ride Inspection Checklist
• What to do before starting the engine.
• Check tire pressure and condition. Recommended cold tire
pressure is 28 psi.
• Check wheels for damage and abnormal play. Make sure lug
nuts are torqued to between 71-105 Nm.
• Check cleanliness of radiator cooling fins.
• Check engine oil level. Maintain between the two notches on dip
stick.
• Check engine coolant level. Maintain between HIGH and LOW
lines on the coolant overflow bottle when engine is cold.
• Check brake fluid level. Maintain between MIN and MAX lines on
the brake fluid reservoir with no pedal pressure.
• Check clutch fluid level. Maintain between MIN and MAX lines on
the clutch fluid reservoir with no pedal pressure.
• Inspect the engine air filter, clean or replace if needed.
– Service engine air filter more often in dusty conditions.
• If you are transporting cargo, respect the maximum rear cargo
weight capacity.
– Ensure cargo is properly secured in the rear cargo area.
– Ensure maximum vehicle load capacity does not exceed
specifications. This includes operator, passengers, added
accessories, trailer tongue weight (if applicable), and rear
cargo
Prepare to Ride
To Next Page
Loading...
Need help?
General
