Mahindra ROXOR HDUV 2024 - Electrical Distribution

119 pages

To Next Page

To Previous Page

13-1

13 Electrical Distribution

Power Distribution Center – This component is located in the

engine bay on the driver side. The Power Distribution Center cover

contains a similar graphic to the one shown here for convenience.

Electrical Distribution

Main Page

Table of Contents5
Introduction9
Improvements9
Engine Tampering Statement9
Getting Started11
Operator's Guide13
Safety Alert Symbols15
Safety Information/General Precautions17
Avoid Carbon Monoxide Poisoning17
Avoid Diesel Fuel Hazards17
Avoid Hot Part Hazards18
Accessories and Modifications18
Safe Operations and Responsibilities21
Owner Responsibilities21
Operator's Responsibilities22
Passenger Responsibilities22
Occupant Restraint System23
Riding Carefully23
Terrain Condition23
Stopping the Engine and Parking24
Important On-Product Labels25
ANSI Labels25
EPA Labels28
Manufacturer Labels29
Riding Gear31
Helmets and Eye Protection31
Additional Riding Gear32
Prepare to Ride33
Pre-Ride Inspection Checklist33
Post-Ride Inspection Checklist35
Learning Your Vehicle37
Vehicle Controls39
Primary Controls39
Keys39
Ignition Switch39
Headlamp Switch41
Multifunction Gauge41
Additional Controls (as Equipped)44
Steering Wheel45
Accelerator Pedal45
Brake Pedal45
Clutch Pedal46
Gear Shift Lever46
Transfer Case Lever46
Equipment47
Seat Belts47
Driver's Seat47
Passenger Seat47
Rollover Protective Structure (ROPS)47
Shoulder Guards (as Equipped)48
Side Nets / Doors48
Passenger Handhold48
Volt Power Outlet49
Storage Compartments49
Cup Bottle Holders49
Rear Cargo Area49
Tailgate49
Fuel Reservoir Cap50
Electrical Distribution51
Fuel (Diesel)55
Fuel Requirements55
Fueling Procedure55
Break in Period57
Operation During Break in57
Tips for Maximizing Durability57
Avoiding Accidents59
OFF-Road Operation61
General Driving Techniques63
Driving Tips63
Driving in Reverse63
Driving in or on Slippery Surfaces64
Driving in or on Sand64
Driving in or on Snow or Ice65
Driving on Hills and Slopes65
Side Hilling66
Drop Offs66
Crossing Obstacles66
Crossing Shallow Water67
Crossing Public Streets, Roads, or Highways67
Driving on Pavement67
Group and Distance Riding68
Environment68
Moving Loads and Doing Work69
Working with Your ROXOR69
Weight and Load Limits69
Loading the Rear Cargo Area69
Carrying Loads70
Hauling and Pulling Loads70
Transporting73
Trailering73
Towing74
Lifting and Supporting75
Maintenance77
Severe Dusty Conditions77
Scheduled Maintenance Chart78
Maintenance Procedures83
Maintenance Tips and Precautions83
Clean Spark Arrester83
Clean and Inspect Brakes84
Check Brake Fluid Level and Leak Check85
Check Differential Oil Levels and Leak Check86
Check Engine Coolant Level and Leak Check86
Check Engine Oil Level and Leak Check87
Check Power Steering Oil Level and Leak Check88
Check Tire Pressure89
Check90
Drain Fuel/ Water Separator90
Lubricate Shift Linkage91
Accessory Drive Belt Tension/Replacement91
Replace Engine Air Filter93
Replace Engine Oil and Oil Filter94
Replace Transfer Case Oil95
Rotate Wheels and Tires96
Vehicle Care97
Post Operation Care97
Vehicle Cleaning and Protection97
Metal and Rust Prevention97
Storage and Preseason Preparation97
Technical Information99
Product Identification Number99
Engine Identification Number99
Noise Emission Control System99
Acts Presumed to Constitute Tampering100
Specifications101
Fluid Specifications and Quantities101
Vehicle Specifications102
Troubleshooting105
Limited and EPA Warranties U.S. and Canada107
Mahindra Emissions Control Warranty Policy107
Contact Us111
Privacy Information113
Change of Address/Ownership115
Stolen Units117

Mahindra ROXOR HDUV 2024 - Electrical Distribution

Table of Contents

Related product manuals