3 - 8
SERVICING SCHEDULE
IMPORTANT
(1): MANDATORY 500 HOUR OR 6 MONTH SERVICE. This service must be carried out after approximately the first 500 hours of operation or within the 6 months following
the start-up of the machine (whichever occurs first).
(2): Every 10 hours during the first 50 hours then a final time at 250 hours.
(3): Contact your dealer.
A = ADJUST, C = CHECK, G = GREASE, N = CLEAN,
P = BLEED, R = REPLACE, V = DRAIN
PAGE (1)
DAILY OR EVERY 10
HOURS OF SERVICE
EVERY 50 HOURS
OF SERVICE
EVERY 250 HOURS
OF SERVICE
EVERY 500 HOURS
OF SERVICE
OR EVERY YEAR
EVERY 1000 HOURS
OF SERVICE OR
EVERY TWO YEARS
EVERY 2000 HOURS
OF SERVICE OR
EVERY TWO YEARS
EVERY 3000 HOURS
OF SERVICE
EVERY 4000 HOURS
OF SERVICE
OCCASIONALLY
ENGINE
- Engine oil level 3-10 C
- Cooling liquid level 3-10 C C
- F
uel level 3-10 C C
- F
uel pre-filter 3-11 C
- Radiator core 3-14 N N
- C
ompressor belt tension (Air conditioning OPTION) 3-20 C/A C/A
- Eng
ine oil 3-22 V V
- Engine oil filter 3-22 R R
- Fuel pre-filter cartridge 3-23 R R
- Fuel filter cartridge 3-23 R R
- Dry air filter cartridge 3-26 R
- Engine crankcase ventilation filter 3-26 R
- Fuel tank 3-27 N
- Engine silent blocks C (3)
- Engine rates C (3)
- Valves clearances C C (3)
- Cooling liquid 3-30 V
- Radiator C (3)
- Water pump and the thermostat C (3)
- Alternator and the starter motor C (3)
- Turbocompressor C (3)
- Safety dry air filter cartridge 3-34 R
- Alternator belt 3-34 R
- Fuel circuit 3-36 P
- "Stationary lift truck" exhaust particle filter 3-36/37 XXX
TRANSMISSION
- Gear box oil level 3-14 C
- Gear box oil 3-27 V V
- G
ear box oil filter 3-27 R R
- Silentblocks in the gear box C (3)
- Gear box controls C (3)
- Transmission pressures C (3)
- Wear of the brake pads and the brake disk C (3)
TYRES
- Tyre pressures 3-15 C C
- Wheel nut torques 3-15 C C
- W
heel nut tightening torque 3-30 C C
- W
heel 3-37 R
BOOM
- Boom pads 3-11 G (2)
- Boom 3-16/17 G G
- Boom pad wear C (3)
- Condition of boom unit C C (3)
- Bearings and articulation rings C (3)
HYDRAULICS
- Hydraulic oil level 3-18 C C
- Hydraulic oil 3-24/31 C V
- Hydraulic return oil filter cartridge
3-28
R
- Breather for the hydraulic oil tank 3-30/31 R
- Suction strainer for hydraulic oil tank 3-30/31 N
- Brake accumulator unit filter 3-30/31 R
- Hydraulic pump tubular filter N (3)
- Condition of hoses and flexible pipes C (3)
- Condition of cylinders (leakage, shafts) C (3)
- Hydraulic circuit pressures C (3)
647104 (13/06/2016)
MT 835 / 1135 / 1335 ST3B
To Next Page
Loading...