Master Forge 820-0033 - Page 12

12
INSTALLATION INSTRUCTIONS
WARNING
Checkallgassupplyttingsforleaksbeforeeachuse.DO NOT use the grill until all connections
have been checked and do not leak. DO NOT smoke while leak testing. NEVER leak test with an
opename.Makeasolutionofonepartliquiddetergentandonepartwater.Youwillneedaspray
bottle,brush,orragtoapplythesolutiontothettings.Fortheinitialleaktest,makesuretheliquid
propane cylinder is full.
TO TEST
1. Turn the burner valves off.
2. Turntheliquidpropanecylindervalvecounterclockwisetoopenthevalve.
3. Applythesoapsolutiontoallgasttings.Soapbubbleswillappearwherealeakispresent.
4. Ifaleakispresent,immediatelyturnthegassupply“OFF”andtightenleakyttings.
5. Turn the gas back “ON” and recheck.
6. Shouldthegascontinuetoleakfromanyofthettings,turnthegassupply“OFF”andcontact
customer service at 1-800-963-0211.
7. If there is evidence of excessive abrasion or wear, or the hose is cut, it must be replaced prior to
the outdoor cooking gas appliance being put into operation.
•Onlythosepartsrecommendedbythemanufacturershouldbeusedonthegrill.Substitutionswill
void the warranty.
WARNING
DO NOT store grill indoors unless the cylinder is disconnected. DO NOT store cylinder in a building,
garage, or any other enclosed area, and keep out of reach of children at all times.
INSTALLER FINAL CHECK
Maintainspeciedclearanceof24inchesfromcombustiblematerialsandconstruction.
•Allinternalpackaginghasbeenremoved.
•Thehoseandregulatorareproperlyconnectedtotheliquidpropanecylinder.
•Theunithasbeentestedandisfreeofleaks.
•Thegassupplyshutoffvalvehasbeenlocated.
•Allburnersareinstalled.
•Keeptheinstructionmanualforfuturereference.
WARNING
•Thegrillanditsindividualshutoffvalvemustbedisconnectedfromthegassupplypipingsystem
during any pressure testing of that system at test pressure in excess of 1/2-in. PSI (3.5 kpa).
•Theoutdoorcookinggasappliancemustbeisolatedfromthegassupplypipingsystembyclosing
its individual manual shutoff valve during any pressure testing of the gas supply piping system at
testpressureequaltoorlessthan1/2-in.PSI(3.5kpa).
•DO NOTstorespareliquidpropanecylindersunderornearthisappliancetoavoidtheriskofre
which could cause death or serious injury.
•NEVERllthecylinderbeyond80percentcapacity.Failuretodosocouldresultinarecausing
death or serious injury.
Lowes.com/masterforge