Master Forge 820-0033 - Operating Instructions; Lighting the Grill Safely; Turning the Grill Off

13
OPERATING INSTRUCTIONS
LIGHTING THE GRILL
1. Place the legs in up position.
2. Make sure the propane cylinder is tightly threaded into the regulator (hand
tighten only).
3. Open lid. ALWAYS open lid when lighting.
4. Push and turn main burner knob slowly to IGNITE/HIGH; burner should light
immediately.
5. If ignition does not occur in 3-5 seconds, turn the control knob “OFF”. Wait 5
minutes before attempting to re-light the grill. If the grill fails to ignite after the
second attempt, call customer service at 1-800-963-0211 for assistance.
Note: If the knob can’t spark insert the match into the lighting rod. Ignite the
match and insert through the cooking grids to the burner.
TURNING THE GRILL OFF
1. Turn knob to “OFF” position.
2. Turn the propane cylinder control knob to the “OFF” position.
CAUTION: DO NOT attempt to re-light the grill without following all
the lighting instructions.
3. Allow the grill body to cool at least 30 minutes before attempting to
move or transport.
FLAME CHARACTERISTICS
Checkforproperburneramecharacteristics.Burneramesshould
be blue and stable with no yellow tips, excessive noise, or lifting.
Thefollowingstepsshouldbefollowedforcorrectingtheame
characteristics:
•Turnthecontrolknobsandliquidpropanecylindervalves“OFF.”
•Allowthegrillandburnerstocool.
•Iftheameisyellow(notenoughair),turntheadjustmentscrewfoundat
the front of the burner counterclockwise.
•Iftheameisnoisyorliftsawayfromtheburner(toomuchair),turnthe
adjustment screw clockwise.
•Iftheseadjustmentsdonotcorrecttheproblem,contactcustomerserviceat
1-800-963-0211.
OFF
LO
OFF
LO
IGNITE
/ HIGH
IGNITE
/ HIGH
Main Burners
OFF
LO
IGNITE
/ HIGH
1 inch
Lowes.com/masterforge