Mercury 80 Owner's Manual

GENERAL INFORMATION
15
• The boat could move suddenly in a new direction. Such a sharp change in direction can cause occupants
to be thrown out of their seats or out of the boat.
• A rapid reduction in speed. This will cause occupants to be thrown forward, or even out of the boat.
• Impact damage to the outboard and/or boat.
Keep in mind, the most important thing you can do to help reduce injury or impact damage during an impact is
control the boat speed. Boat speed should be kept to a minimum planing speed when driving in waters known
to have underwater obstacles.
After striking a submerged object, stop the engine as soon as possible and inspect it for any broken or loose
parts. If damage is present or suspected, the outboard should be taken to an authorized dealer for a thorough
inspection and necessary repair.
The boat should also be checked for any hull fractures, transom fractures, or water leaks.
Operating a damaged outboard could cause additional damage to other parts of the outboard, or could affect
control of the boat. If continued running is necessary, do so at greatly reduced speeds.
!
WARNING
Avoid serious injury or death from loss of boat control. Continued boating with major impact damage can
result in sudden outboard component failure with or without subsequent impacts. Have the outboard
thoroughly inspected and any necessary repairs made.
Exhaust Emissions
BE ALERT TO CARBON MONOXIDE POISONING
Carbon monoxide is present in the exhaust fumes of all internal combustion engines. This includes the outboards,
sterndrives and inboard engines that propel boats, as well as the generators that power various boat accessories.
Carbon monoxide is a deadly gas that is odorless, colorless and tasteless.
Early symptoms of carbon monoxide poisoning which should not be confused with seasickness or intoxication,
include headache, dizziness, drowsiness, and nausea.
!
WARNING
Avoid the combination of a running engine and poor ventilation. Prolonged exposure to carbon monoxide in
sufficient concentration can lead to unconsciousness, brain damage, or death.
GOOD VENTILATION
Ventilate passenger area, open side curtains, or forward hatches to remove fumes.
21622
Example of desired air flow through the boat
POOR VENTILATION
Under certain running and/or wind conditions, permanently enclosed or canvas enclosed cabins or cockpits with
insufficient ventilation may draw in carbon monoxide. Install one or more carbon monoxide detectors in your
boat.
Although the occurrence is rare, on a very calm day, swimmers and passengers in an enclosed area of a
stationary boat that contains or is near a running engine may be exposed to a hazardous level of carbon
monoxide.

Mercury 80 Specifications

General

Steering	Remote
Shaft Length	20 in (508 mm)
Gear Ratio	2.07:1
Horsepower	80 hp
Full Throttle RPM Range	5000-6000 RPM
Bore x Stroke	3.15 x 3.15 in (80 x 80 mm)