7 SCHEDULED MAINTENANCE
Mitsubishi Diesel Engine S16R & S16R2 OPERATION & MAINTENANCE MANUAL
127
Pub. No. K29001-00320 Revision: 1
*1: If the part is not supplied from Shanghai MHI Engine co., Ltd. (SME), service the part following the
supplier's operation manual.
*2: Replace also the oil filters when the filter alarm lamp is turned on.
*3: Engine oil change intervals for the emergency-use engine vary depending on the installation conditions.
For details, refer to "Engine Oil Service Limits for Emergency Use" (→ Page 208).
Table 7-8 Scheduled Maintenance for Emergency Use Engine (3/5)
Inspection and
Maintenance Period
Service Items
Reference
Page
Service period
Every year
Air starter
system
• Starter Air Strainer - Drain Water and Clean 178
• Starting Air Tank Safety Valve Operation -Check 179
• Air Starter Valve - Check
• Solenoid Valve and Pressure Reducing Valve -
Check and Clean
• Air Distribution Valve -Check
• Air Compressor Belt Tension -Check
8
(Contact your
SME dealer)
• Protection System - Check *1
(High coolant temperature, low oil pressure, overspeeding, start
stalling, cooling water supply fault, undervoltage, overvoltage,
overcurrent, low coolant level in tank, low fuel level in tank, low air
pressure in tank, and others.)
• Auxiliary Devices - Check *1
(Engine control devices, fuel transfer pump, governor motor, room
ventilating fan, solenoid, lifting pump, water tank ball tap, water
heater, oil heater, oil priming pump, and others.)
8
(Contact your
SME dealer)
Every 2 years
• Engine Oil, Oil Filter, and Bypass Oil Filter - Replace *2 *3 159 161 161
• Engine Oil - Analysis (recommended) -
• Fuel Filter - Replace 147
• Water Separator Element - Replace *1 145
• Gauze Filter - Clean 146
• Fuel Control Link Ball Joint -Check
(Replace parts as needed)
150
• Coolant - Change 164
• Thermostat - Check 8
(Contact your
SME dealer)
• Turbocharger - Check 174
• Exhaust Muffler - Drain Water *1 174
• Starting Air Compressor - Overhaul (Air Direct Admission Starting, Air
Motor Starting)
8
(Contact your
SME dealer)
To Next Page
Loading...
