Motorola PTP 54500 - Testing Your Installation

To Next Page

To Previous Page

11 Lightning Protection

160

11.3 Testing Your Installation

If you have followed the above instructions you will have wired your system to the following

diagram:

Figure 97 - Simplified Circuit Diagram

Main Page

Default Chapter3
- Copyright Information3
- Table of Contents8
- Table 1 - Font Types21
- Table 2 - Admonition Types22
- Getting Additional Help23
- Sending Feedback23
1 About this User Guide21
- Interpreting Typeface and Other Conventions21
2 Avoiding Hazards24
- Preventing Overexposure to RF Energy24
- Calculations for Separation Distances and Power Compliance Margins24
- Table 3 - Power Compliance Margins25
3 Getting Started27
- For Your Safety27
- Welcome28
- Who Should Use this Guide28
- Contact Information28
- Repair and Service28
- Table 4 - Contact Information28
- Product Description29
- Figure 1 - Typical PTP 500 Series Bridge Deployment29
- The Outdoor Unit (ODU)30
- Figure 2 - PTP 500 Series Bridge Outdoor Unit (ODU) with PTP-LPU30
- PIDU Plus - PTP 300/500/600 Series Bridge31
- Figure 3 - Power Indoor Unit (PIDU Plus) - PTP 300/500/600 Series31
- Figure 4 - PIDU Plus Recovery Switch Location31
- Redundancy and Alternative Powering Configurations33
- Figure 5 -PTP 300/500/600 Series Bridge PIDU Plus Power Input33
- Figure 6 - External DC Supply Only33
- Figure 7 - External DC Supply and AC Supply34
- Figure 8 - External DC Supply and Redundant AC Supply34
- Remote Leds and Recovery Switch35
- Cables and Connectors35
- Figure 9 - Remote LED and Recovery Switch Wiring35
- PTP and Lightning Protection36
- Mounting Brackets36
- Configuration and Management37
- Warranty37
4 Product Architecture38
- Figure 10 - PTP 500 Series Bridge Layer Diagram39
5 General Considerations41
- Spectrum Planning41
- Table 5 - PTP 500 Series Bridge Frequency Variants41
- Licenses and Region Codes42
- Table 6 - PTP 58500 Licenses and Region Codes43
- Operational Restrictions44
- Radar Avoidance44
- Table 7 - PTP 54500 Licenses and Region Codes44
- Ghz Restrictions45
- Channel Bandwidth Operation46
- Figure 11 - 5.8 Ghz UK RTTT Channel Avoidance - 15 Mhz Channel Bandwidth Only46
- PTP 54500 Specific Frequency Planning Considerations47
- PTP 54500 Raster Considerations47
- Transmit Power Reduction at the Band Edges47
- Figure 12 - 5.4 Ghz Available Spectrum Settings - 15 Mhz Channel Bandwidth47
- PTP 58500 Specific Frequency Planning Considerations48
- PTP 58500 Raster Considerations48
- Figure 13 - 5.8 Ghz Available Spectrum Settings - 15 Mhz Channel Bandwidth48
- Ptp49
- 58500 Transmit Power Reduction at the Band Edges49
- Table 8 - PTP 58500 FCC Max Transmit Power at the Edge Channels (FCC)49
- Distance50
- Networking Information50
- Lightning Protection and Regulations50
- Electrical Requirements50
6 Site Planning51
- Site Selection Criteria51
- ODU Site Selection51
- PTP 500 Series Bridge PIDU Plus Site Selection51
- Path Loss Considerations52
- Definitions52
- Modulation Mode54
- Table 9 - PTP 54500 - IP Mode -System Threshold Figures - 15Mhz BW54
- Table 10 - PTP 54500 - TDM Mode - System Threshold Figures - 15 Mhz BW55
- PTP 58500 Product Variant - Link Loss, Output Power and System Threshold Versus Modulation Mode56
- Table 11 - PTP 58500 - IP Mode -System Threshold Figures - 15 Mhz BW56
- Table 12 - PTP 58500 - TDM Mode -System Threshold Figures - 15 Mhz BW57
7 Installation58
- Preparation58
- Installation Procedure58
- Tools Required59
- Installation Support59
- Legal Disclaimer59
- Mounting the Odus60
- Figure 14 - Mounting to Pole Diameters 25Mm (1") to 50Mm (2")60
- Figure 15 - Integral Safety Loop61
- Connecting up62
- Preparing the PIDU Plus to ODU Cable62
- Figure 16 - Correct Cable Preparation for the Recommended Cable62
- Figure 17 - Completed ODU Connector63
- Figure 18 - Warning Not to over Tighten Cable Gland63
- Making the Connections at the ODU64
- Figure 19 - PTP 500 Series Bridge PIDU Plus Connexion64
- Making the PTP 300/500/600 Series Bridge PIDU Plus Connection at the ODU65
- Figure 20 - Connecting the PIDU+ to the ODU65
- Routing the Cable66
- Fitting a Lightning Protection Unit66
- Figure 21 - Disconnecting the ODU66
- Grounding the Installation67
- Making the ODU Connection at the PTP 300/500/600 Series Bridge PIDU Plus67
- Making the Network Connection at the PIDU Plus - PTP 500 Series Bridge68
- Mounting the PTP 300/500/600 Series Bridge PIDU Plus68
- Figure 22 - Making the Network Connection at the PIDU Plus68
- Figure 23 - PTP 500 Series PIDU Plus Drip Loop Configuration69
- Powering up70
- Aligning the PTP 500 Series Bridge Odus71
- Table 13 - Audio Indications from the ODU71
- Table 14 - Graphical Installation Behavior72
- Figure 24 - Using DVM for Alignment73
- Additional Installation Notes74
8 Web75
- Figure 25 - Menu Navigation Bar76
- Home Page - PTP 500 Series Bridge77
- Figure 26 - System Summary Page77
- Home Page Alarm Display78
- Figure 27 - Alarm Warning Triangle78
- Systems Status Page83
- Figure 28 - Status Page83
- Equation 2 - Link Loss86
- System Administration88
- Figure 29 - System Administration Login Page88
- System Configuration89
- Figure 30 - System Configuration Page89
- Figure 31 - LAN Configuration Page91
- Figure 32 - Configuration Reboot Page92
- Figure 33 - Configuration Reboot Page - Ethernet Auto Negotiation Disabled92
- Figure 34 - VLAN Configuration Fields93
- Figure 35 - Qos Configuration Page94
- Table 15 - Qos Default Settings95
- Table 16 - Classification Rules Upgrade Example95
- Table 17 - IEEE802.1Q Classification Rules96
- Figure 36 - Save and Restore Configuration Page97
- Figure 37 - Save Configuration File Screen98
- Figure 38 - PTP 500 Example Configuration File98
- Figure 39 - Restore Configuration File Pop up Screen99
- Figure 40 - Reset Configuration and Reboot Confirmation Pop-Up100
- Statistics Page101
- Figure 41 - System Statistics101
- Detailed Counters Page104
- Figure 42 - Detailed Counters Page104
- Install106
- Table 18 - 500 Series Bridge Factory Configuration Values106
- Figure 43 - License Key Data Entry107
- Figure 44 - Installation Wizard Internet Protocol Configuration108
- Figure 45 - VLAN Warning109
- Figure 46 -PTP 58500 and PTP 54500 Variants - Installation Wizard Wireless Configuration110
- Figure 47 -PTP 58500 and PTP 54500 Variants - Fixed Frequency Operation113
- Figure 48 -PTP 58500 and PTP 54500 Variants - Installation Wizard Confirm Configuration114
- Figure 49 - Reboot Confirmation Pop up114
- Figure 50 -PTP 58500 and PTP 54500 Variant - Disarm Installation115
- Figure 51 - Optional Post Disarm Configuration 2116
- Graphical Install117
- Figure 52 - Graphical Installation Screen117
- Software Upgrade118
- Figure 53 - Software Upgrade118
- Figure 54 - Software Upgrade Image Check119
- Figure 55 - Software Download Progress Indicator120
- Figure 56 - Software Upgrade Complete120
- Spectrum Management121
- Figure 57 - Reboot Confirmation Pop up121
- Figure 58 - Spectrum Management as Seen from the Master124
- Figure 59 - Spectrum Management as Seen from the Slave124
- Figure 60 - Active Channel History Screen127
- Table 19 - Spectrum Management Change State Key127
- Figure 61 - Spectrum Management Time Series Plot128
- Table 20 - Spectrum Management Time Series Key128
- Spectrum Management (Fixed Frequency)129
- Figure 62 - Spectrum Management Fixed Frequency Screen129
- Spectrum Management Control - with Operational Restrictions130
- Figure 63 - Spectrum Management Help Page (Fixed Frequency)130
- Figure 64 - Spectrum Management Master Screen with Operational Restrictions131
- Figure 65 - Spectrum Management Slave Screen with Operational Restrictions132
- Table 21 - Spectrum Management Change State Key with Operational Restrictions133
- Remote Management Page134
- Figure 66 - Remote Management134
- Figure 67 - Warning When Disabling HTTP Interface135
- Figure 68 - Remote Management - Diagnostic Alarms136
- Diagnostics139
- Figure 69 - Diagnostic Plotter140
- Figure 70 - CSV Download141
- Change System Administration Password142
- License Key142
- Figure 71 - Password Change142
- Figure 72 - Software License Key Data Entry142
- Properties143
- Figure 73: License Key Reboot Screen143
- Figure 74 - Reboot Confirmation Pop up143
- Figure 75 - Properties143
- Reboot144
- Figure 76 - System Reboot144
- Figure 77 - Reboot Confirmation Pop up144
9 Recovery Mode145
- Figure 78 - Recovery Mode Warning Page145
- Figure 79 - Recovery Options Page145
- Upgrade Software Image146
- Figure 80 - Software Download Progress Indicator Page147
- Figure 81 - Software Download Complete Page147
- Figure 82 - Reboot Confirmation Pop up147
- Reset IP & Ethernet Configuration148
- Figure 83 - Confirm Reset to Factory Default Pop up148
- Figure 84 - IP and Ethernet Erased Successfully Page148
- Erase Configuration149
- Figure 85 - Reboot Confirmation Pop up149
- Figure 86 - Confirm Erase Configuration Pop up149
- Figure 87 - Erase Configuration Successful Page149
- Erase Security Parameters150
- Figure 88 - Erase Configuration - Reboot Confirmation Pop up150
- Figure 89 - Confirm Zeroise Security Parameters Pop up150
- Reboot151
- Figure 90 - Zeroise Security Parameters Successful Page151
- Figure 91 - Recovery - Reboot Confirmation Pop up151
10 Fault Finding152
- Hardware152
- Power152
- Ethernet153
- Checking Your Wiring154
- Table 22 - Power Indoor Unit LED Check Chart154
- Radio155
- No Activity155
- Some Activity156
11 Lightning Protection157
- Overview157
- Lightning Protection Zones157
- Figure 92 - ODU Mounted in Zones a & B158
- Detailed Installation159
- Figure 93 - Showing How the Use of a Finial Enables the ODU to be Mounted Inside Zone B159
- Figure 94 - Diagrammatically Showing Typical Mast and Wall Installations160
- Figure 95 - PTP LPU Installation Example for PTP 500 Series (Not to Scale)160
- Figure 96 - PTP 500 Series LPU Kit161
- Testing Your Installation162
- Figure 97 - Simplified Circuit Diagram162
- Pre-Power Testing163
- Table 23 - Resistance Table Referenced to the RJ45 at the PIDU163
- Post-Power Testing164
- Locating the Fault165
- Figure 98 - PTP LPU Test Points165
12 Wind Loading166
- General166
- Calculation of Lateral Force166
- Table 24 - Lateral Force - Imperial166
- Table 25 - Lateral Force - Metric166
- Capabilities of the PTP 500 Series Bridges167
- Wind Speed Statistics167
13 PTP 500 Series Bridge - Connectorized Model168
- Scope168
- Product Description168
- Hardware168
- Figure 99 - Connectorized 500 Series Bridge Outdoor Unit168
- Antenna Choices - 5.8 Ghz169
- Suggested Antenna Choices - 5.4 Ghz169
- Software/Features170
- Status Page170
- Figure 100 - Connectorized 500 Series Bridge Status Page170
- Configuration171
- Figure 101 - Connectorized 500 Series Bridge 'System Configuration' Page171
- Installation172
- Figure 102 - Connectorized PTP 500 Series Bridge 'Installation Wizard' Page172
- Figure 103 - Connectorized 500 Series Bridge 'Confirm Installation' Page173
- Deployment Considerations174
- Figure 104 - Connectorized 500 Series Bridge 'Disarm Installation' Page174
- Link Budget175
- Regulatory Issues175
- Antenna Choice (FCC and Industry Canada Regions Only)176
- Cable Losses (FCC Regions Only)176
- Table 26 - Cable Losses Per Length176
- Antennas for USA / Canada - 5.8 Ghz177
- Table 27 - Allowed Antennas for Deployment in Usa/Canada – 5.8 Ghz179
- Suggested Antennas - 5.4 Ghz180
- Table 28 - Suggested Antennas – 5.4 Ghz181
- Installation182
- Antenna Choice182
- Cables and Connectors182
- Tools182
- Miscellaneous Supplies183
- Mounting the Connectorized 500 Series Bridge183
- Mounting the Antennas183
- Alignment Process183
- Aligning Dual Polar Antennas184
- Aligning Separate Antennas184
- Completing the Installation185
- Antenna Cable Fixing185
- Antenna Connection Weatherproofing186
- Figure 105 - Forming a Drip Loop186
- Figure 106 - Weatherproofing the Antenna Connections186
- Additional Lightning Protection187
- ODU Mounted Outdoors187
- Figure 107- Additional Grounding When Using Connectorized Units187
- ODU Mounted Indoors188
- Figure 108 - Lightning Arrestor Mounting188
- Figure 109 - Polyphaser Assembly188
14 Data Rate Calculations189
- Figure 110 - BPSK 0.50 Single Payload189
- Figure 111 - QPSK 0.50 Single Payload190
- Figure 112 - QPSK 0.75 Single Payload190
- Figure 113 - 16 QAM 0.50 Single Payload191
- Figure 114 - 16 QAM 0.75 Single Payload191
- Figure 115 - 64 QAM 0.67 Single Payload192
- Figure 116 - 64 QAM 0.83 Single Payload192
- Figure 117 - QPSK 0.50 Dual Payload193
- Figure 118 - QPSK 0.75 Dual Payload193
- Figure 119 - 16 QAM 0.50 Dual Payload194
- Figure 120 - 16 QAM 0.75 Dual Payload194
- Figure 121 - 64 QAM 0.67 Dual Payload195
- Figure 122 - 64 QAM 0.83 Dual Payload195
15 AES Encryption Upgrade196
- Configuring Link Encryption196
- License Keys196
- Figure 123 - AES Software License Key Data Entry197
- Encryption Mode and Key198
- Figure 124 - AES Configuration Data Entry Page198
- Wireless Link Encryption FAQ199
- Encryption Data Entry Fields Are Not Available199
- Link Fails to Bridge Packets after Enabling Link Encryption199
- Loss of AES Following Downgrade199
- Figure 125 - Configuration Reboot Screen199
16 Legal and Regulatory Notices200
- Important Note on Modifications200
- National and Regional Regulatory Notices - PTP 58500 Variant200
- Federal Communication Commission (FCC) and Industry Canada (IC) Notification200
- European Union Notification201
- UK Notification202
- National and Regional Regulatory Notices - PTP 54500 Variant203
- FCC and Industry Canada (IC) Notification203
- European Union Notification204
- Exposure205
- Legal Notices206
- Motorola Inc. End User License Agreement206
- Hardware Warranty in U.S215
- Limit of Liability215
17 Specifications216
- System Specifications216
- Wireless PTP 54500 Variant216
- Wireless PTP 58500 Variant217
- Management218
- Ethernet Bridging218
- Physical219
- Powering219
- Safety Compliance219
- EMC Emissions Compliance220
- PTP 54500 Variant220
- PTP 58500 Variant220
- EMC Immunity Compliance221
- Radio Certifications222
- PTP 54500 Variant222
- PTP 58500 Variant222
- Environmental Specifications222
- System Connections223
- PIDU Plus to ODU and ODU to Network Equipment Connections223
- Figure 126 - Cable Connection Diagram (T568B Color Coding)223
18 Faqs224
19 Glossary226
20 Index227

Motorola PTP 54500 - Testing Your Installation

Table of Contents

Related product manuals