Napoleon GD80NT - Table of Contents

2
W415-0695 / C / 03.19.12
TABLE OF CONTENTS
1.0 INSTALLATION OVERVIEW 3
2.0 INTRODUCTION 4
2.1 DIMENSIONS 5
2.2 GENERAL INSTRUCTIONS 5
2.3 GENERAL INFORMATION 6
2.4 RATING PLATE INFORMATION 7
3.0 VENTING 8
3.1 VENTING LENGTHS AND COMPONENTS 9
3.2 TYPICAL VENT INSTALLATION 10
3.3 SPECIAL VENT INSTALLATION 11
3.3.1 PERISCOPE TERMINATION 11
3.4 MINIMUM AIR TERMINAL LOCATION CLEARANCES 12
3.5 VENTING APPLICATION FLOW CHART 13
3.6 DEFINITIONS 13
3.7 ELBOW VENT LENGTH VALUES 13
3.8 TOP EXIT HORIZONTAL TERMINATION 14
3.9 VERTICAL TERMINATION 16
4.0 INSTALLATION 18
4.1 WALL AND CEILING PROTECTION 18
4.1.1 HORIZONTAL INSTALLATION 19
4.1.2 VERTICAL INSTALLATION 19
4.2 USING FLEXIBLE VENT COMPONENTS 20
4.2.1 HORIZONTAL AIR TERMINAL INSTALLATION 20
4.2.2 VERTICAL AIR TERMINAL INSTALLATION 21
4.2.3 APPLIANCE VENT CONNECTION 22
4.3 MOBILE HOME INSTALLATION 22
4.4 GAS INSTALLATION 23
5.0 FRAMING 24
5.1 MINIMUM CLEARANCE TO COMBUSTIBLES 26
5.2 MINIMUM CLEARANCE TO COMBUSTIBLE ENCLOSURES 27
5.3 ALCOVE FRAMING 29
5.4 MINIMUM MANTEL CLEARANCES 30
6.0 FINISHING 31
6.1 DOOR REMOVAL / INSTALLATION 31
6.2 LOG SHIPPING BRACKET 32
6.3 DECORATIVE BRICK PANEL INSTALLATION 33
6.4 LOG PLACEMENT 34
6.5 GLOWING EMBERS 35
6.6 CHARCOAL EMBERS 35
7.0 OPERATION 36
7.1 GENERAL TRANSMITTER LAYOUT 36
7.2 APPLIANCE OPERATION 36
7.3 HAND HELD REMOTE OPERATIONS 37
7.4 TEMPERATURE DISPLAY 37
7.5 ROOM THERMOSTAT 37
7.6 SMART THERMOSTAT 37
7.7 FLAME HEIGHT 38
7.8 FAN SPEED 38
7.9 CHILD PROOF FUNCTION 38
7.10 NIGHT LIGHTS
TM
39
7.11 LOW BATTERY / MANUAL BYPASS 39
7.12 IN THE EVENT OF A POWER FAILURE 39
7.13 CONTROL MODULE 40
7.14 TIMED BLOWER 40
8.0 ELECTRICAL INFORMATION 41
8.1 HARD WIRING CONNECTION 41
9.0 OPERATING INSTRUCTIONS 42
10.1 PILOT BURNER ADJUSTMENT 43
10.0 ADJUSTMENT 43
10.2 VENTURI ADJUSTMENT 43
10.3 FLAME CHARACTERISTICS 44
10.4 AIR CONTROL ROD ACCESS 44
11.0 MAINTENANCE 45
11.1 INNER ACCESS PANEL 45
11.2 NIGHT LIGHT
TM
REPLACEMENT 46
11.3 BLOWER REPLACEMENT 46
11.4 REMOTE RECEIVER REMOVAL 47
11.5 VALVE REMOVAL 47
11.6 “AUTO SPARK” BATTERY REMOVAL 48
11.7 CARE OF GLASS 48
11.8 RESTRICTING VERTICAL VENTS 48
12.0 REPLACEMENTS 49
13.0 TROUBLESHOOTING 53
14.0 WARRANTY 56
15.0 SERVICE HISTORY 57