Napoleon HD4N - Table of Contents

W415-1146 / A / 02.16.13
2
EN
NOTE: Changes, other than editorial, are denoted by a vertical line in the margin.
TABLE OF CONTENTS
1.0 INSTALLATION OVERVIEW 3
2.0 INTRODUCTION 4
2.1 DIMENSIONS 5
2.1.1 SEE-THRU (HD4ST, HD4STG AND HD4STC) 5
2.1.2 PENINSULA (HD4P, HD4PG AND HD4PC) 5
2.2 GENERAL INSTRUCTIONS 6
2.3 GENERAL INFORMATION 7
2.4 RATING PLATE / LIGHTING INSTRUCTION LOCATION 8
3.0 VENTING 9
3.1 VENTING LENGTHS AND COMPONENTS 10
3.2 TYPICAL VENT INSTALLATIONS 11
3.3 SPECIAL VENT INSTALLATIONS 12
3.3.1 PERISCOPE TERMINATION 12
3.4 VENT TERMINAL CLEARANCES 13
3.5 VENT APPLICATION FLOW CHART 14
3.6 DEFINITIONS 14
3.7 ELBOW VENT LENGTH VALUES 14
3.8 HORIZONTAL TERMINATION 15
3.9 VERTICAL TERMINATION 17
4.0 INSTALLATION 19
4.1 WALL AND CEILING PROTECTION 19
4.1.1 HORIZONTAL INSTALLATION 20
4.1.2 VERTICAL INSTALLATION 20
4.2 USING FLEXIBLE VENT COMPONENTS 21
4.2.1 HORIZONTAL AIR TERMINAL INSTALLATION 22
4.2.2 VERTICAL AIR TERMINAL INSTALLATION 23
4.2.3 APPLIANCE VENT CONNECTION 23
4.3 GAS INSTALLATION 24
4.4 MOBILE HOME INSTALLATION 24
5.0 FRAMING 25
5.1 FRAMING 26
5.1.1 SEE-THRU FRAMING 26
5.1.2 PENINSULA FRAMING 26
5.2 MINIMUM CLEARANCE TO COMBUSTIBLE ENCLOSURES 27
5.3 INSTALLING CEMENT BOARD 28
5.3.1 FINISHING SUPPORT ADJUSTMENT 29
5.4 NON-COMBUSTIBLE FACING MATERIAL 30
5.5 ALCOVE ENCLOSURE 31
5.6 MINIMUM MANTEL CLEARANCES 32
6.0 FINISHING 33
6.1 DOOR REMOVAL / INSTALLATION 33
6.2 END DOOR REMOVAL / INSTALLATION 34
6.3 HEARTH PAD INSTALLATION (HD4ST AND HD4P ONLY) 34
6.4 LOG PLACEMENT (HD4ST AND HD4P ONLY) 35
6.5 GLASS MEDIA INSTALLATION 37
6.6 OPTIONAL ROCK PLACEMENT (HD4STC AND HD4C ONLY) 37
6.7 LOGO PLACEMENT 38
7.0 ELECTRICAL CONNECTION 38
7.1 HARD WIRING CONNECTION 38
7.2 RECEPTACLE WIRING DIAGRAM 39
7.3 BATTERY BACK-UP INSTALLATION 39
7.4 WIRING DIAGRAM 40
8.0 OPERATING INSTRUCTIONS 41
8.1 OPERATING INSTRUCTIONS - FOR YOUR SAFETY READ BEFORE OPERATING 41
8.2 LIGHTING INSTRUCTIONS 41
8.3 ANTI CONDENSATION SWITCH 42
9.0 ADJUSTMENT 43
9.1 PILOT BURNER ADJUSTMENT 43
9.2 VENTURI ADJUSTMENT 43
9.3 FLAME CHARACTERISTICS 44
10.0 MAINTENANCE 45
10.1 ANNUAL MAINTENANCE 45
10.2 GLASS / DOOR REPLACEMENT 46
10.3 CARE OF GLASS 46
10.4 BURNER REMOVAL 47
10.4.1 LOG BURNER REMOVAL (HD4ST AND HD4P ONLY) 47
10.4.2 GLASS BURNER REMOVAL (HD4STG AND HD4PG ONLY) 47
10.4.3 GLASS AND ROCK BURNER REMOVAL (HD4STC AND HD4PC ONLY) 48
10.5 VALVE TRAIN REPLACEMENT 48
10.6 RESTRICTING VERTICAL VENTS 48
11.0 REPLACEMENTS 49
12.0 TROUBLESHOOTING 52
13.0 WARRANTY 55