EasyManua.ls Logo

Napoleon ROGUE 525-1 - User Manual

Napoleon ROGUE 525-1
24 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
EN
PG.17
www.napoleon.com
N415-0580-AU REV - MAY 11.22
WARNING
Do not try to light this appliance without

this manual.

liquids or vapors near this appliance.





death.
DANGER
IF YOU SMELL GAS:
• 
• 
• Open lid.
• 
appliance and immediately call your gas

APPLY SERIAL NUMBER LABEL FROM CARTON
Serial No.
XXXXXX000000
MODEL NO.


DO NOT DISCARD



Wolf Steel Ltd.
214 Bayview Drive,
Barrie, Ontario, CANADA L4N 4Y8
grills@napoleon.com

!
!
IAPMO GMK10539
AS/NZS 5263.1.7

Table of Contents

Questions and Answers

  • W
    William MckenzieAug 14, 2025
    Why is the Napoleon Grill not getting hot enough?
    • S
      sullivandavidAug 14, 2025
      If your Napoleon Grill exhibits low heat or a low flame even when the valve is set to high, it might be due to an improper lighting procedure. Ensure you follow the lighting procedure carefully: all gas grill valves must be in the off position when you turn on the tank valve. Turn the tank on slowly to allow pressure to equalize. Another potential cause is improper preheating. Make sure to preheat the grill with the main burners on high for 10 minutes.
  • H
    Holly HuffAug 17, 2025
    How to stop flare-ups on Napoleon ROGUE 525-1?
    • M
      mashleyAug 17, 2025
      Excessive flare-ups or uneven heat in your Napoleon Grill can be caused by several factors. First, check that the sear plates are installed correctly, with the holes towards the front and the slots on the bottom. Refer to the assembly instructions for guidance. Improper preheating can also contribute to this issue, so ensure you preheat the grill with the main burners on high for 10 minutes. Lastly, excessive grease and ash buildup on the sear plates and in the drip pan can cause flare-ups. Clean these components regularly, and avoid lining the drip pan with aluminum foil. Refer to the cleaning instructions for proper cleaning procedures.
  • J
    Jonathan DavisAug 25, 2025
    Why does my Napoleon Grill have a yellow flame?
    • K
      Keith NealAug 25, 2025
      If the burners on your Napoleon Grill are burning with a yellow flame and accompanied by the smell of gas, it could be due to a spider web or other debris obstructing the burner. Thoroughly clean the burner by removing it. See the general maintenance instructions for guidance. Another potential cause is an improper air shutter adjustment. In this case, slightly open the air shutter according to the combustion air adjustment instructions. Note that this adjustment must be performed by a qualified gas installer.
  • S
    Spencer JamesAug 27, 2025
    What to do if Napoleon ROGUE 525-1 Grill flames lift away from burner?
    • D
      Deborah DanielsAug 27, 2025
      If the flames lift away from the burner on your Napoleon Grill, accompanied by the smell of gas, and you're experiencing difficulties in lighting, it's likely due to an improper air shutter adjustment. Close the air shutter slightly according to the combustion air adjustment instructions. Please note that this adjustment must be done by a qualified gas installer.
  • L
    Lynn TateAug 30, 2025
    Napoleon ROGUE 525-1 igniter not working, how to fix?
    • P
      Paul ShawAug 30, 2025
      If the main burner on your Napoleon Grill will not light with the igniter but will light with a match, the jet-fire outlet may be dirty or clogged. Clean the jet-fire outlet with a soft bristle brush.
  • D
    David PattersonSep 2, 2025
    Why is 'paint' peeling inside my Napoleon ROGUE 525-1 lid?
    • C
      charles65Sep 2, 2025
      If you observe what appears to be 'paint' peeling inside the lid or hood of your Napoleon Grill, this is not a defect. The finish on the lid and hood is porcelain and will not peel. The peeling is caused by hardened grease, which dries into paint-like shards that flake off. Regular cleaning will prevent this. See the cleaning instructions for guidance.
  • D
    David SmithSep 6, 2025
    Napoleon ROGUE 525-1 Grill burners won't cross light, what to do?
    • J
      Jonathan NielsenSep 6, 2025
      If the burners on your Napoleon Grill will not cross light each other, it could be due to dirty or corroded cross light brackets. Clean or replace the brackets as required.
  • J
    Jessica SmithSep 9, 2025
    Why is my Napoleon Grill regulator humming?
    • J
      Jill KelleySep 9, 2025
      A humming regulator on your Napoleon Grill is a normal occurrence on hot days. This is not a defect. It is caused by internal vibrations in the regulator and does not affect the performance or safety of the gas grill. Humming regulators will not be replaced.
  • A
    Austin TorresNov 19, 2025
    Why is my Napoleon ROGUE 525-1 burner output too low?
    • W
      William PorterNov 19, 2025
      If the burner output on the 'high' setting of your Napoleon Grill is too low, accompanied by a rumbling noise and fluttering blue flame at the burner surface, several issues could be responsible. Start by checking the gas level in your ULPG cylinder to ensure you have enough gas. Inspect the supply hose to make sure it isn't pinched, and reposition it if necessary. A dirty or clogged orifice can also restrict gas flow, so clean the burner orifice. Spider webs or other material in the venturi tube can also cause this issue, so clean out the venturi tube. Finally, the ULPG regulator might be in a 'low flow' state. Ensure you follow the lighting procedure carefully: all gas grill valves must be in the off position when the tank valve is turned on. Turn the tank on slowly to allow pressure to ...

Summary

Location

Locating Your Outdoor Gas Grill

Guidance on selecting a safe and appropriate outdoor placement for the gas grill.

General Information

Natural Gas Hook-Up

Instructions for connecting the gas grill to a natural gas supply line.

Universal Liquefied Petroleum Gas Cylinder Specifications

Gas Hook-Up Instructions

Step-by-step guide for connecting the gas grill to a ULPG cylinder.

Maintenance Instructions

Combustion Air Adjustment

How to adjust the air shutter for optimal burner flame and performance.

Adjusting the Air Shutter

Detailed steps for adjusting the air shutter on the gas grill burners.

Burner Care and Spider Warning

Beware of Spiders

Warning about insects nesting in burners and how to clean them.

Aluminum Castings Cleaning

Cleaning Aluminum Surfaces

How to clean and refinish aluminum casting surfaces on the grill.

Getting Started

ULPG Proper Hose Connection

Instructions and warnings for connecting the ULPG hose to the grill.

Napoleon ROGUE 525-1 Specifications

General IconGeneral
TypeGas Grill
Cooking Area525 sq. in.
Burners4
MaterialStainless Steel
Weight140 lbs
Fuel TypePropane
Grill MaterialStainless Steel

Related product manuals