SP Series
Operating & Safety Instructions
USA – 11/14
Original instructions
2.1.8 This machine contains several hazardous substances such as but not limited to: Battery acid, Hydraulic
Fluid, Engine Coolant, Antifreeze, LPG, Diesel Fuel, Engine Oil, Grease, Gasoline.
2.1.9 Covers and canopies should remain closed when the machine is in operation. Only trained personnel
should carry out maintenance on the machine, ensuring at all times they protect themselves from
electrical, heat and mechanical hazards.
2.1.10 Never exceed the maximum basket capacity, as indicated on the decals and machine serial plate.
2.1.11 Only operate the Niftylift on a firm, level surface.
2.1.12 Never position any part of the Niftylift within the Minimum Approach Distances of any electrical power
line, conductor, or similar stated in Occupational Safety and Health Administration Regulations for CFR
1910.333(c) for Minimum Approach Distance for electrical wires.
1910.333(c)(3)(i)(A)(1): For voltages to ground 50kV or below - 10 feet (305 cm);
1910.333(c)(3)(i)(A)(2): For voltages to ground over 50kV - 10 feet (305 cm) plus 4 inches (10 cm)
for every 10kV over 50kV.
THIS MACHINE IS NOT INSULATED.
If in doubt, contact the appropriate authorities
2.1.13 On entering the basket ensure that the drop down entry bar is closed afterwards.
THE BASKET FLOOR MUST BE WITHIN 19.5" OF THE GROUND WHEN ENTERING
OR EXITING. THIS IS ACHIEVED ON LEVEL GROUND BY TELESCOPING OUT 5 FT
1" DO NOT CLIMB IN OR OUT OF THE BASKET WITH THE BOOMS IN THE
TRANSPORT POSITION.
2.1.14 Use of an approved safety belt and lanyard, hard hat and appropriate safety clothing is mandatory.
Fasten harness to designated harness securing points within the basket and do not remove until leaving
the basket whilst in the stowed position.
2.1.15 Always remain standing within the basket. Do not attempt to increase your height or
reach by standing and/or climbing on the basket guard rails or any other object.
KEEP YOUR FEET ON THE BASKET FLOOR. Do not sit, stand or climb on the guard
rail, mid rail or boom linkage. Use of planks, ladders or any other devices on the
Niftylift for achieving additional height or reach shall be prohibited.
2.1.16 Do not use the basket levelling system to artificially increase the outreach of the Niftylift. Never use
boards or ladders in the basket to achieve the same result.
2.1.17 Do not use the basket to lift overhanging or bulky items that may exceed the maximum capacity or
carry objects that may increase the wind loading on the basket. (e.g. Notice boards etc.)
2.1.18 The Niftylift shall not be operated from a position on trucks, trailers, railway cars, floating vessels,
scaffolds or similar equipment unless the application is approved in writing by Niftylift Ltd in Great
Britain.
2.1.19 Always check that the area below and around the basket is clear of personnel and obstructions before
lowering or rotating the booms. Care should be taken when rotating the booms out into areas where
there may be passing traffic. Use barriers to control traffic flow or prevent access to the machine.
To Next Page
Loading...
