What to do if Nilfisk-Advance Floor Machine wheel drive works in one direction only?
If the wheel drive on your Nilfisk-Advance Floor Machine only works in one direction, you should repair the wiring or replace the R1 pot and replace the (A1) speed control.
Why won't the wheel drive motor run in forward and reverse on my Nilfisk-Advance Floor Machine?
Several factors can prevent the wheel drive motor from running in both directions. Here's what to check: * **Batteries:** Ensure they are fully charged and recharge if necessary. * **Circuit Breakers:** Look for tripped breakers, specifically the Wheel Drive Motor Circuit Breaker (F2) and the Control Circuit Breaker (F4), and reset them. * **Parking Brake:** Make sure the parking brake is released. * **Emergency Stop Switch:** Verify the Emergency Stop Switch (13) is not tripped; reconnect the battery to reset it. * **Safety Switch:** Check the Safety Switch (S2) in the seat to confirm it's closed. * **Motor:** The Wheel Drive Motor might be defective and need replacement. * **Throttle Potentiometer:** A defective Throttle Potentiometer (R1) may also be the cause, requiring ...
Explains safety symbols and provides critical safety instructions.
Details daily, weekly, monthly, and yearly maintenance tasks.
Checklist for operational inspection of machine systems.
Checklist for visual inspection of machine components.
Guide to troubleshoot common wheel drive system problems.
Adjusting brakes and testing/installing the potentiometer.
Guide to troubleshoot vacuum performance and system maintenance.
Guidelines for battery maintenance, charging, and testing.
Methods for diagnosing controller faults using display or programmer.
Overview of control board, error codes, test modes, and special options.
Wiring diagrams and schematics for various serial number ranges.
General| Model | BR 600S |
|---|---|
| Category | Floor Machine |
| Type | Ride-On Scrubber |
| Working Width | 24 in (61 cm) |
| Cleaning Path | 24 in (61 cm) |
| Brush Speed | 200 rpm |
| Max Speed | 6 km/h |
To Next Page