EasyManuals Logo

Omron E3AS-HL500MT 2M User Manual

Omron E3AS-HL500MT 2M
12 pages
To Previous Page IconTo Previous Page
To Previous Page IconTo Previous Page
Page #12 background imageLoading...
Page #12 background image
LaserOFF/Teaching/Zeroresetselectable
Fortheappliedvoltage,referto"2-1Input/OutputCircuitDiagram"(page2). Fortheinputtime,referto"3-3ExternalInput"(page3).
Reversedpowerpolarityprotection,Outputshort-circuitprotection,andOutputreversepolarityprotection
OLEDDisplay(White),Power/Communicationindicator(Green),Operationindicator(Orange)
1.5ms/10ms/50msselectable
4unitsmax.(whenusingthemutualinterferencepreventionfunction)
Operating:-10to+50℃(withnoicingorcondensation)Storage:-25to+70℃(withnoicingorcondensation)
Operating:35to85%RH,Storage:35〜95%RH(withnocondensation)
20MΩmin.at500VDC
1,000VACat50/60Hzfor1minute
10to55Hz,1.5-mmdoubleamplitudefor2hourseachinX,Y,andZdirections
500m/s
2
for3timeseachinX,Y,andZdirections
IP67(IEC60529),IP69K(ISO20653),IP67G(JISC0920Annex1)
Pre-wiredtype:48.6×30.4×15.5mm,Connectortype:47.1×28.9×15.5mm
SUS316L
Polyamide11(PA11)
Methacrylicresin(PMMA)(Lenscover:Antifoulingcoating)
Ver1.1
COM3:230.4kbps,COM2:38.4kbps
PDsize:4byte,ODsize:1byte(M-sequencetype:TYPE2V)
COM3:1.2ms,COM2:3.5ms
Spotsize(referencevalue)*2
Lightsource(wavelength)
Powersupplyvoltage
Consumptioncurrent
35to500mm
Receiversurfaceilluminance:
Incandescentlamp:20,000lxmax.,Sunlight:25,000lxmax.atdistanceof250mm
Incandescentlamp:5,000lxmax.,Sunlight:10,000lxmax.atdistanceof500mm
Receiversurfaceilluminance:
Incandescentlamp:8,000lxmax.,Sunlight:16,000lxmax.
35to150mm
RatingsandSpecifications
8
Externalinput
Protectioncircuits
Indicator
Responsetime
Mutualinterferenceprevention
Ambientillumination
Ambienttemperature
Ambienthumidity
Insulationresistance
Dielectricstrength
Vibrationresistance
Shockresistance
Enclosureratings
Dimensions
Material
Conformitystandards
Controloutput
Sensingdistance
Standarddetectable
difference*1
Communication
specifications
Case
E3AS-HL500MN□series
E3AS-HL500MD□series
E3AS-HL500MT□series
2.5×1.5mmatdistanceof500mm 18×1.5mmatdistanceof500mm
ULCertification,CEMarking,RCM,EAC,IEC60825-1:2014(LaserClass1),FDA(LaserClass1),Ecolab,RoHs2,WEEE2
2.5×1.3mmatdistanceof150mm 8×1.3mmatdistanceof150mm
E3AS-HL500LMN□series
E3AS-HL500LMD□series
E3AS-HL500LMT□series
E3AS-HL150MN□series
E3AS-HL150MD□series
E3AS-HL150MT□series
E3AS-HL150LMN□series
E3AS-HL150LMD□series
E3AS-HL150LMT□series
NPNoutput
PNPoutput/COM2
PNPoutput/COM3
Model
Triangulation
Sensingmethod
Indicator
LenscoverandDisplay
IO-Linkspecification
Baudrate
Datalength
Minimumcycletime
■Modelstandard
Triangulation
500mm
150mm
Spot
Line
Red
Metal
NPNopencollector
PNPopencollector/COM2
PNPopencollector/COM3
HL
500
150
Blank
L
Blank
M
N
D
T
Mark
Sensingmethod
Specification
Sensingdistance
Emissionspotshape
Lightsource
Casematerial
Outputmethod
E3AS-HL M □
   ②③④⑤⑥⑦⑧
Note:1.Altitude:Upto2000m,Pollutiondegree:3,Enclosuretype:Type1.
*1.MeasuredwithOMRON'sstandardworkpiece(Whiteceramic).
*2.DefinedbyD4σmethodatthemaximumsensingdistance.Detectionmaybeinfluencedifthereislightleakageoutsidethedefinedregionandthe
surroundingsofthetargetobjecthaveahighreflectanceincomparisontothetargetobject.Also,whendetectingaworkpiecethatissmallerthanthespot
size,acorrectvaluemaynotbeobtained.
Pre-wired
Pre-wiredM12SmartclickConnector
Pre-wiredM8Connector
M8Connctor
Specialspecification
M8Connector
2m+150/-0mm(Pre-wired)
5m+150/-0mm(Pre-wired)
0.3m+60/-0mm(Pre-wiredConnector)
Blank
‐M1TJ
‐M3J
M3
alphanumericalcharacter
Blank
2M
5M
0.3M
Connectionmethod
Optionalsuffix
Codelength
Suitability for Use
t
OMRON Corporation shall not be responsible for conformity with any standards, codes or
regulations which apply to the combination of the Product in the Buyer’s application or use of
the Product. At Buyer’s request, Omron will provide applicable third party certification
documents identifying ratings and limitations of use which apply to the Product. This
information by itself is not sufficient for a complete determination of the suitability of the
Product in combination with the end product, machine, system, or other application or use.
Buyer shall be solely responsible for determining appropriateness of the particular Product
with respect to Buyer’s application, product or system. Buyer shall take application
responsibility in all cases.
NEVER USE THE PRODUCT FOR AN APPLICATION INVOLVING SERIOUS RISK TO LIFE
OR PROPERTY WITHOUT ENSURING THAT THE SYSTEM AS A WHOLE HAS BEEN
DESIGNED TO ADDRESS THE RISKS, AND THAT THE OMRON PRODUCT(S) IS
PROPERLY RATED AND INSTALLED FOR THE INTENDED USE WITHIN THE OVERALL
EQUIPMENT OR SYSTEM.
D
OMRON Corporation
Industrial Automation Company
Contact: www.ia.omron.com
Kyoto, JAPAN
OMRON ELECTRONICS LLC
2895 Greenspoint Parkway, Suite 200
Hoffman Estates, IL 60169 U.S.A.
Tel: (1) 847-843-7900/Fax: (1) 847-843-7787
OMRON ASIA PACIFIC PTE. LTD.
No. 438A Alexandra Road # 05-05/08 (Lobby 2),
Alexandra Technopark,
Singapore 119967
Tel: (65) 6835-3011/Fax: (65) 6835-2711
OMRON (CHINA) CO., LTD.
Room 2211, Bank of China Tower,
200 Yin Cheng Zhong Road,
PuDong New Area, Shanghai, 200120, China
Tel: (86) 21-6023-0333/Fax: (86) 21-5037-2388
OMRON EUROPE B.V.
Wegalaan 67-69, 2132 JD Hoofddorp
The Netherlands
Tel: (31)2356-81-300/Fax: (31)2356-81-388
Regional Headquarters
Loadpowersupplyvoltage30VDCmax.(Class2),thetotalloadcurrentofthetwooutputsis100mAmax.
Residualvoltage(Loadcurrent10mAmax.:1VDCmax.,Loadcurrent10to100mA:2VDCmax.)
Opencollectoroutputtype(DependsontheNPN/PNPoutputtype)N.O.(NormallyOpen)/N.C.(NormallyClose)selectable
Redlaser(660nm)
10to30VDC,(includingripple(p-p)10%),Class2
100mAmax.
35to180mm9mm
180to300mm18mm
300to400mm30mm
400to500mm45mm
at10msec
35.0to50.0mm1mm
50.0to100.0mm2mm
100.0to150.0mm4mm
at10msec
12

Questions and Answers:

Question and Answer IconNeed help?

Do you have a question about the Omron E3AS-HL500MT 2M and is the answer not in the manual?

Omron E3AS-HL500MT 2M Specifications

General IconGeneral
BrandOmron
ModelE3AS-HL500MT 2M
CategoryAccessories
LanguageEnglish

Related product manuals