Panasonic NN­GS595A - 4.12 Lower Heater Replacement

10/24/2016 XMLServiceManual
file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/inde…
9/9
1.PleasegreaseenoughsiliconevenlybetweentheinterfaceofheaterDUandbottomofovencavity.(about0.3mm
thickness),thisisforgoodconductibility.
2.Tighten4screwsandmakesurethereisnogapbetweenheaterDUandbottomofovencavity.
3.DonotforgettoscrewthethermalcutoutbracketalongwithheaterDu.
Toinstallthermistor
NOTE:
Beforeinstallingthermistor,pleasefillenoughsilicongreaseintotheinstallationholeofheaterDUforgoodconductibility.
4.12Lowerheater
1.Removetubesfrombothendsofcopperpipe.
2.Remove1screwholdingairguideBonthebase.
3.Removeleftandrightdoorkeyspringsfromdoorarm.
NOTE:
Pleasesupportdoorbeforeoperation.
4.Turnoverthemicrowaveovenandremoveallscrewsholdingbaseonovenassy&twohinges.
NOTE:
Donotremovetwoscrewsholdingleftandrighthingeonthebottomofcavityfrontplate.
5.Removebasefromovenassy.
6.Disconnect2leadwiresfromtherightsideoflowerheater.
7.Remove2screwslinkingtheterminalsoflowerheater.
8.Usetoolssuchasplierstoturnoutthetablocatedontheleftsideoflowerheater.