Paul CLIMOS F 200 Basic - Default Chapter; Table of Contents; Table of Content

Table of Content
2
Table of Content
Table of Content ................................................................................................................................................ 2
1 Type plate ................................................................................................................................................ 3
2 Principal configuration of the system ..................................................................................................... 4
3 Replacement of the filters ....................................................................................................................... 5
3.1 Replacement of the filters of the device ................................................................................................. 5
3.2 Resetting the filter run-time ................................................................................................................... 9
4 Replacement of the heat exchanger ..................................................................................................... 10
5 Replacement of the master board, slave board and BUS thermostat .................................................. 14
6 Replacement of the fan ......................................................................................................................... 22
7 Replacement of the defroster heating (preheater) .............................................................................. 31
8 Replacement of the over-temperature protection switch (STB) / temperature controller at the
defroster (preheater) ............................................................................................................................ 39
9 Replacement of the temperature sensor .............................................................................................. 47
10 Messages, errors and error handling .................................................................................................... 55
10.1 Error signalling by means of the LED control panel .............................................................................. 55
10.2 Visualisation of errors with the TFT touch panel .................................................................................. 55
11 Error handling ........................................................................................................................................ 57
11.1 Error fan ................................................................................................................................................ 57
11.2 Error temperature sensor ..................................................................................................................... 58
11.3 Communication error defroster ............................................................................................................ 59
11.4 Communication error fan slave ............................................................................................................. 60
11.5 TFT without communication ................................................................................................................. 61
11.6 Error intake air too low ......................................................................................................................... 62
11.7 Error supply air too low ......................................................................................................................... 63
11.8 Fan too noisy ......................................................................................................................................... 64
11.9 Heat recovery too low ........................................................................................................................... 65
11.10 Failure or problems without a message ................................................................................................ 66
Appendix .......................................................................................................................................................... 67
Appendix 1 Circuit diagram CLIMOS F 200 Basic – status: 05.11.2013 .......................................................... 67
Appendix 2 Circuit diagram CLIMOS F 200 Comfort – status: 05.11.2013 .................................................... 68
Notes ............................................................................................................................................................... 69