Perkins 854F-E34T - Page 115

Engine Operation............................................. 56
System Check.............................................. 56
Engine Operation with Active Diagnostic
Codes ............................................................ 49
Engine Operation with Intermittent
Diagnostic Codes........................................... 49
Engine Protection Plans (Extended Service
Contract).......................................................113
Engine Starting ...........................................14, 53
Engine Stopping .........................................14, 64
F
Fan Clearance - Check.................................. 100
Fault Logging................................................... 49
Features and Controls ..................................... 32
Fire Prevention and Explosion Prevention ...... 10
Fire Extinguisher.......................................... 12
Lines, Tubes, and Hoses ............................. 12
Regeneration ............................................... 12
Fluid Recommendations.............................72, 74
ELC Cooling System Maintenance.............. 77
Engine Oil .................................................... 73
General Coolant Information........................ 74
General Lubricant Information ..................... 72
Fluid Recommendations (Fuel Specification).. 66
Diesel Fuel Characteristics ......................... 69
Diesel Fuel Requirements ........................... 66
General Information ..................................... 66
Foreword............................................................ 4
California Proposition 65 Warning ................. 4
Literature Information..................................... 4
Maintenance .................................................. 4
Maintenance Intervals.................................... 4
Operation ....................................................... 4
Overhaul ........................................................ 4
Safety............................................................. 4
Fuel and the Effect from Cold Weather............ 62
Fuel Conservation Practices............................ 59
Fuel Related Components in Cold Weather .... 62
Fuel Filters ................................................... 63
Fuel Heaters ................................................ 63
Fuel Tanks.................................................... 62
Fuel System - Prime ...................................... 101
Fuel System Primary Filter (Water
Separator) Element - Replace ..................... 102
Install the Element ..................................... 103
Remove the Element ................................. 102
Fuel System Primary Filter/Water Separator
- Drain .......................................................... 104
Fuel System Secondary Filter - Replace ....... 104
Install the Element ..................................... 105
Remove the Element ................................. 104
Fuel Tank Water and Sediment - Drain.......... 106
Drain the Water and the Sediment............. 106
Fuel Storage Tanks .................................... 106
Fuel Tank ................................................... 106
G
Gauges and Indicators .................................... 32
Aftertreatment Lamps .................................. 33
Indicator Lamps ........................................... 33
General Hazard Information .............................. 6
Asbestos Information..................................... 8
Containing Fluid Spillage ............................... 8
Dispose of Waste Properly............................. 9
Fluid Penetration............................................ 8
Pressurized Air and Water ............................. 7
General Information......................................... 17
H
High Pressure Fuel Lines ................................ 12
Hoses and Clamps - Inspect/Replace ........... 106
Replace the Hoses and the Clamps .......... 107
I
Important Safety Information ............................. 2
L
Lifting and Storage........................................... 30
M
Maintenance Interval Schedule ....................... 83
Commissioning ............................................ 83
Daily ............................................................. 83
Every 1000 Service Hours ........................... 83
Every 12 000 Service Hours or 6 Years ....... 83
Every 1500 Service Hours ........................... 83
Every 2000 Service Hours ........................... 83
Every 3000 Service Hours ........................... 83
Every 3000 Service Hours or 2 Years.......... 83
Every 4000 Service Hours ........................... 83
Every 50 Service Hours or Monthly ............. 83
Every 50 Service Hours or Weekly .............. 83
Every 500 Service Hours ............................. 83
Every 500 Service Hours or 1 Year.............. 83
SEBU8726 115
Index Section