Porter-Cable PCC620 - Troubleshooting; Maintenance; Replacement Parts

10
Troubleshooting
Problem Possible Cause Possible Solution
•Unitwillnotstart.  •Batterypacknotinstalledproperly. •Checkbatterypack
installation.
    •Batterypacknotcharged.  •Checkbatterypack
       chargingrequirements.
•Batterypackwillnotcharge. •Batterypacknotinsertedintocharger. •Insertbatterypackinto
charger until LED
lights.
   •Chargernotpluggedin.  •Plugchargerintoa
working outlet. Refer to
“Important Charging Notes”
for more details.
    •Surroundingairtemperature •Movechargerandbattery
too hot or too cold. pack to a surrounding air
       temperatureofabove40
       degreesF(4,5°C)orbelow
       105degreesF(+40,5°C).
SPECIAL NOTES FOR USE WITH LITHIUM BATTERIES
•Unitshutsoffabruptly. •Batterypackhasreachedits •Allowbatterypacktocool
    maximumthermallimit.  down.
    •Outofcharge.(To •Placeonchargerand
maximize the life of the allow to charge.
battery pack it is designed
to shutoff abruptly when
the charge is depleted.)
For assistance with your product, visit our website at www.portercable.com for a list of
servicecenters,orcallthePORTER-CABLECustomerCareCenterat(888)848-5175.
The RBRC™ Seal
TheRBRC™(Rechargeable
BatteryRecyclingCorporation)
SealontheLi-Ionbattery(or
batterypack)indicatesthatthe
coststorecyclethebattery(orbatterypack)
at the end of its useful life have already
beenpaidbyPORTER-CABLE.
RBRC™incooperationwithPORTER-CABLE
and other battery users, has established
programs in the United States to facilitate
thecollectionofspentLi-Ionbatteries.Help
protect our environment and conserve natural
resourcesbyreturningthespentLi-Ionbattery
toanauthorizedPORTER-CABLEservice
center or to your local retailer for recycling.
You may also contact your local recycling
center for information on where to drop off the
spent battery.
RBRC™ is a registered trademark of the
Rechargeable Battery Recycling Corporation.
Maintenance
Use only mild soap and damp cloth to
cleanthetool.Neverletanyliquidget
inside the tool; never immerse any part of
thetoolintoaliquid.
Replacement Parts
Use only identical replacement parts. For a
parts list or to order parts, visit our service
website at www.portercable.com. You can also
orderpartsfromyournearestPORTER-CABLE
FactoryServiceCenterorPORTER-CABLE
Authorized Warranty Service Center. Or, you
can call our Customer Care Center at
(888) 848-5175.
This Class B digital apparatus complies
withCanadianICES-003.
Thisdevicecomplieswithpart15ofthe
FCC rules. Operation is subject to the
followingtwoconditions:(1)Thisdevice
may not cause harmful interference, and
(2)thisdevicemustacceptanyinterference
received, including interference that may
cause undesired operation.
NOTE: Thisequipmenthasbeentested
and found to comply with the limits for
a Class B digital device, pursuant to
Part15oftheFCCRules.Theselimits
are designed to provide reasonable
protection against harmful interference in
aresidentialinstallation.Thisequipment
generates, uses and can radiate radio
frequencyenergyand,ifnotinstalledand
used in accordance with the instructions,
may cause harmful interference to radio
communications.However,thereisno
guarantee that interference will not occur
in a particular installation.
Ifthisequipmentdoescauseharmful
interference to radio or television
reception, which can be determined
byturningtheequipmentoffandon,