IMPORTANT
READ ALL OF THE FOLLOWING WARNINGS AND
STATEMENTS BEFORE READING THE
INSTALLATION INSTRUCTIONS
WARNING
This boiler, gas piping and accessories must be
installed, connected, serviced and repaired by a
trained, experienced service technician, familiar with
all precautions required for gas-fired equipment and
licensed or otherwise qualified, in compliance with the
authority having jurisdiction.
WARNING
The venting system of this boiler is under positive pressure
when it is connected to the outdoors with 76 mm (3") diame-
ter pipe. Leakage from this system can be hazardous and if
not avoided can result in death or serious injury. In addition
to the recommendations within this manual and the User’s
Information Manual, the venting system, from the blower to
the outdoor discharge, must be carefully checked annually
by a qualified service agency.
This manual must be left
with owner and should be
hung on or adjacent to
the boiler for reference.
V
ICTORY VSPH
™
INSTALLATION AND OPERATING INSTRUCTIONS
Publication No. VSPH-40 Part No. 455035 Printed in Canada 0408
Rev. C
Heating Contractor
Address
Phone Number
Boiler Model Number
Boiler Serial Number
Installation Date
DIRECT-VENT SEALED COMBUSTION BOILERS
HOT WATER MODELS VSPH-60 THROUGH VSPH-180
GAS-FIRED CAST-IRON BOILERS FOR NATURAL AND L.P. PROPANE GASES
TABLE OF CONTENTS
Dimensions, Rating and Orifice Sizes.........................................2
Identification of Parts...................................................................3
Installation Requirements ............................................................4
Venting Application......................................................................5
Boiler Room Air Supply and Ventilation......................................5
Flue Gas Venting Requirements .................................................5
Vent Material ...............................................................................5
Air Intake Material .......................................................................6
Flue and Air Intake Restrictions ..................................................6
Non-Direct Vent Installation.........................................................8
Sidewall Venting, Non-Direct Vent ..............................................8
Vent Termination Location and Clearance..................................8
Non-Direct Vent Vertical Venting .................................................8
Direct Vent Installation.................................................................8
Sidewall Venting, Direct Vent ......................................................8
Vent/Air Intake Termination Installation .......................................8
Direct Vent, Venting and Air Intake through a Roof..................13
Venting and Air Intake Regular Inspection ...............................15
Gas Piping .................................................................................15
Electrical Wiring .........................................................................15
Multi Zoning ...............................................................................18
Water Piping ..............................................................................18
Wiring Diagram..........................................................................16
Operating Instructions ...............................................................19
Gas Input Rate Adjustment .......................................................20
Boiler Control.............................................................................22
Sequence of Operation .............................................................21
Status of Indicator Lights (LED’s) .............................................22
Safety Check ............................................................................23
Care and Maintenance ..............................................................24
General Troubleshooting Guide...........................................25-27
WARNING
LIQUEFIED PETROLEUM (L.P.)
PROPANE GAS-FIRED BOILERS
Installation location ONLY as permitted in paragraph entitled
"LIQUEFIED PETROLEUM (L.P.) PROPANE GAS-FIRED
BOILER LOCATION" on page 4 of this instruction book.
The above warning does not apply to NATURAL gas-
fired boilers.
The installation must conform to the requirements of the
authority having jurisdiction or, in the absence of such
requirements, to the National Fuel Gas Code, ANSI Z223.1-
latest edition or
CSA B149.1-00 for natural gas and
propane. The installation must also conform to the
additional requirements in this Slant/Fin Instruction Book.
In addition, where required by the authority having jurisdic-
tion, the installation must conform to American Society of
Mechanical Engineers Safety Code for Controls and Safety
Devices for Automatically Fired Boilers, No. CSD-1 or
CSA
B149.1-00 for natural gas and propane. If there is any
conflict in the above requirements, then the more stringent
requirement will apply.
®
To Next Page
Need help?
General
