Snorkel SL26-01 Series Operating Manual

SL30SL – 8210037
Table of Contents
Electrical Danger ............................ Inside Front Cover
California Proposition 65 ................ Inside Front Cover
Chapter 1 – Introduction
Aerial Platform Features ............................................. 1
Options .......................................................................1
Operator’s Manual ......................................................1
Safety Alerts ...............................................................1
Operation .................................................................... 1
Maintenance ...............................................................2
Manual of Responsibilities .......................................... 2
Additional Information ................................................. 2
Chapter 2 – Specications
Component Identication ............................................ 3
General Specications................................................4
Engine Specications .................................................5
Engine Oil Viscosity ....................................................5
Chapter 3 – Safety
Electrocution Hazards ................................................7
Minimum Safe Approach Distance .............................7
Prestart Inspection......................................................8
Work Place Inspection and Practices .........................8
Operation .................................................................... 8
Tip-Over and Falling Hazards .....................................9
Electrical System ........................................................9
Hydraulic System........................................................9
Engine and Fuel Handling Precautions ....................10
Placards and Decals.................................................10
Chapter 4 – Safety Devices
Emergency Stop Controls......................................... 11
Upper Controls Emergency Stop Override ............... 11
Emergency Lowering Knob ...................................... 11
Guardrails .................................................................12
Lanyard Anchors.......................................................12
Tilt Alarm ...................................................................12
Speed Level..............................................................12
Engine Protection Systems ......................................13
High Engine Temperature Alarm ...........................13
Low Oil Pressure Alarm ......................................... 13
Horn Button ..............................................................13
Lowering Alarm ......................................................... 13
All Motion Alarm........................................................13
Flashing Light ...........................................................13
Chapter 5 – Gauges and Displays
Display Screen .........................................................15
Hour Meter ............................................................15
Fuel Gauge ............................................................... 15
Engine Oil .................................................................15
Hydraulic Fluid Level Gauge ....................................16
Engine Air Filter Gauge ............................................16
Chapter 6 – Controls
Lower Controls .........................................................17
On/Off Switch ........................................................17
Preheat Button ......................................................17
Start Button ...........................................................17
Emergency Stop Button ........................................17
Upper Controls Emergency Stop Override ............17
Enable Button ........................................................ 17
Platform Raise Button ...........................................17
Platform Lower Button ........................................... 17
Upper Controls .........................................................18
Preheat Button ......................................................18
Start Button ...........................................................18
Emergency Stop Button ........................................18
Joystick .................................................................18
Interlock Switch .....................................................19
Steer Switch ..........................................................19
High Speed Drive ..................................................19
Low Speed Drive ...................................................19
Platform Raise/Lower Button ................................19
Speed Level Button ...............................................19
Horn Button ...........................................................20
Chapter 7 – Prestart Inspection
Operator’s Manual ....................................................21
Engine ......................................................................21
Oil Level ................................................................21
Coolant ..................................................................21
Radiator ................................................................. 22
Fuel Tank ............................................................... 22
Fuel Line ...............................................................22
Air Filter .................................................................22
Electrical System ......................................................22
Battery Terminals ...................................................23
Cables and Wiring Harness ...................................... 23
Hydraulic System......................................................23
Fluid Level .............................................................23
Fluid Filter .............................................................24
Hoses, Tubes, and Fittings .................................... 24
Tires and Wheels ......................................................24
Lower Control Station ...............................................24
Operating Controls ................................................25
Emergency Stop .................................................... 25
Emergency Lowering ................................................ 25
Upper Controls Emergency Stop Override ...............26
Lowering Alarm ......................................................... 26
All Motion Alarm........................................................26
Flashing Light ...........................................................26
Structures .................................................................26
Weldments ............................................................26
Fasteners ..............................................................26
Upper Control Station ...............................................26
Guardrail System ..................................................26
Lanyard Anchors.......................................................27
Operating Controls ................................................27
Emergency Stop .................................................... 28
Horn Button ...........................................................28
Placards and Decals.................................................28
Prestart Inspection Checklist ....................................32

Snorkel SL26-01 Series Specifications

General

Brand	Snorkel
Model	SL26-01 Series
Category	Lifting Systems
Language	English