Stels UTV800 - Page 99

- 96 -
ITEM ROUTINE
Whichever
Comes first
→
INTIAL
EVERY
month 1 3 6 6 12
Km
(mi)
320
(200)
1,200
(750)
2,400
(1,500)
2,400
(1,500)
4,800
(3,000)
hours 20 75 150 150 300
Front brake*
●
Check operation/brake pad wear/fluid leakage.
●
Correct if necessary. Replace pads if worn to the limit.
○ ○ ○ ○ ○
Rear brake*
●
Check operation/brake pad wear/fluid leakage.
●
Correct if necessary. Replace pads if worn to the limit.
○ ○ ○ ○ ○
Accelerator pedal* ●Check operation and free play. ○ ○ ○ ○ ○
Wheels*
●
Check balance/damage/ runout .
●
Repair if necessary.
○ ○ ○ ○
Wheel bearings*
●
Check bearing assemblies for looseness/damage..
●Replace if damaged.
○
○ ○ ○
Front and rear
Suspension*
●
Check operation and for leakage.
●
Correct if necessary.
○ ○
Steering system*
●
Check operation and for looseness/Replace if damage.
●
Check toe-in/Adjust if necessary.
○ ○ ○ ○ ○
Rear upper and lower knuckle pivots* ●Lubricate with lithium-soap-based grease.
○
○
○
Drive shaft universal joint* ●Lubricate with lithium-soap-based grease.
○
○
○
Engine mount*
●
Check for cracks or damage.
●
Correct bolt tightness.
○ ○ ○
Front and rear axle boots*
●
Check operation.
●Replace if damage.
○
○
Stabilizer bushings* ●Check for cracks or damage.
○
○
○
Fittings and fasteners*
●
Check all chassis fittings and fasteners.
●
Correct if necessary.
○ ○ ○ ○ ○
NOTE :
● Recommended brake fluid: DOT4
● Brake fluid replacement:
● Replace the brake hoses every four years, or if cracked or damaged.
● When disassembling the master cylinder or caliper, replace the brake fluid.
Normally check the brake fluid level and add fluid as required.
● On the inner parts of the master cylinder and caliper, replace the oil seals every two years.