FINE CYCLO Operating Manual
FC_GB_01_05 NO.991051 Issue: 01/05 page 1
Copyright 2005 All rights reserved
Reproduction in part or whole is not permitted without
our prior approval.
Whilst every care has been taken in preparation of this
manual, no liability can be accepted for any errors or
omissions.
Subject to technical changes.
Content:
1. General information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
2. Safety advice . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
3. Transportation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
4. Connection of other transmission components . . . . . . . . . . . .2
5. Installation procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
5.1 Necessary tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
5.2 Assembly tolerances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
5.3 To check before installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
5.4 Getting the unit ready for installation . . . . . . . . . . . . . . . . . . . . . . .3
5.5 Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
6. Safety advise for installation of the reduction assembly . . . . .3
6.1 Do not disassemble the reduction parts . . . . . . . . . . . . . . . . . . . . .3
6.2 Protect the reduction assembly . . . . . . . . . . . . . . . . . . . . . . . . . . .3
6.3 Do not exchange components . . . . . . . . . . . . . . . . . . . . . . . . . . .3
6.4 Accuracy of assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
6.5 Observation of tigtening torques
. . . . . . . . . . . . . . . . . . . . . . . . . .
4
6.6 Safety advice for explosion protection
. . . . . . . . . . . . . . . . . . . . . .
4
6.7 Safety advice for use with motor/frequency inverter . . . . . . . . . . . . .5
7. Before starting up in hazardeous area . . . . . . . . . . . . . . . . . . .5
8. Disfunctions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
9. FC-A . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
10. F1C-A . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
11. F2C-A . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
12. F3C-A . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13
13. F2C-T . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14
To Next Page
Loading...
Need help?
General