- 24 - - 5 -
CENTREX 2000 FAMILY PART NUMBERS & DESCRIPTIONS
Symptom Cause Remedial Action Prevention
Drum Will
Not Turn
Drum Door
Not
Opening/
Closing
Properly
Waste Not
Exiting
Waste Pipe
or Gas
Bubbles at
Toilet
Set screw securing
handle to shaft has
broken
Steel pin securing
gear wheel to shaft
has broken
Drum fallen from
bearings.
Drum too full
Hinges Stuck
Waste pipe blocked
1. Drill out set screw and use tap to re-thread
hole.
2. Replace with Screw #10-32x 1 1/4" Hex
Socket Stainless Steel set.
3. If unavailable, call Sun-Mar for a replace-
ment. Serial number of the Centrex 2000
will be required.
Have your serial number ready and call Sun-Mar
for a replacement Small Gear Kit.
Have your serial number ready.
If the drum has fallen, contact Sun-Mar immedi-
ately. Serial number of the Centrex 2000 will be
required.
See Section on “Compost Troubleshooting- Drum
Too Full”
Drum Hinges have compost caked on them.
Spray with Compost Quick and clean with nylon
brush. This will push the obstruction away so
the door swings freely.
1. Ensure piping installation remains as per
“Installation Instructions” (See earlier sec-
tion), and modify if necessary.
2. Follow “Periodic Check Up” recommenda-
tions and options.
3. If still blocked, install clear-out port as per
“Instructions” (See earlier section) and
clear with plumbing snake.
Keep composting drum from
becoming overloaded. This puts
undue strain on the nylon gear.
Not a common repair.
Drum should never be more than
1/2 full.
# PART DESCRIPTION # PART DESCRIPTION
1
PP-INLEP-0207CX Centrex Waste Inlet
17
(Incl. In Heating Element Kit) Insulation
2
AO-ACCEP-0481BX Access Port
18
AO-THERA-0001AX Thermostat
3
PP-BUSH0-0812XX Bushing Threaded
19
AO-HEATE-0311XX Heating Element C9286-1
4
AO-SMALL-0440XX Nylon Drive Gear
20
PM-ALUMS-0811EX Aluminum Sheet
5
AO-SHAFA-0851XX SS Shaft Kit
21
AO-DRUML-0469BX Drum Locker
6
AO-FAN_A-0315KX Fan Assembly (Electric & AC/DC)
22
PP-SCRE00-0821EX Drum Locker Knobt
7
PP-GASK0-0188XX Rubber Gasket
23
PP-INTAV-0797XX Air Intake Vent
8
PP_DRUM0-0624CX Centrex 2000 Drum
24
PF-TANKC-0761EX Centrex 2000 Tank
9
PP-BEARP-0758RX Bearing Plate
25
PP-BEARS-0787CX Drum Bearing Strip
10
PP-GASK0-0188BX Rubber U Channel
26
AM-DRUMS-0329EX Drum Screen
11
AP-DRAI0-0306EX Drain Assembly
27
AO-DRUMD-2004EX Drum Door
12
PF-EVAPT-0789EX Evaporating Tray
28
AO-DRUMD-2004EX Drum Door
13
PF-DRAW1-0764EX Centrex 2000 Drawer
29
AO-HANDL-3000EX Swivel Handle
14
P0-ELECB-0001AX Electric Box Assembly (Electric and AC/DC)
30
PP-TOPC2-0802BX Centrex 2000 Top Kit
15
PF-HEAT1-0760EX Centrex 2000 Heater Tray
30
PP-TOPC2-0802DX Centrex 2000 NE Top
16
PP-GASK0-0188BX Rubber U Channel
30
PP-TOPC2-0802CX Centrex 2000 AC/DC Top
31
PP-INLEP-0207CX Waste Inlet Pipe
To Next Page
Loading...
