Suzuki DF350A - Table of Contents

Table of Contents 0- i
0
Section 0
CONTENTS
General Information
General Information ................................ 0A-1
General Description.............................................0A-1
Symbols ..............................................................0A-1
Abbreviations ......................................................0A-2
Wire Color Symbols ............................................0A-3
Warning, Caution and Information Label
Locations...........................................................0A-3
Outboard Motor Identification Number
Location ............................................................0A-4
Fuel and Oil Recommendations..........................0A-4
Break-In Procedures ...........................................0A-5
Propeller Selection Guide ...................................0A-6
Battery Requirement ...........................................0A-6
Powerhead Direction of Rotation Description .....0A-6
Specifications.......................................................0A-7
Specifications......................................................0A-7
Service Data .......................................................0A-9
Tightening Torque Specifications......................0A-14
Special Tools and Equipment...........................0A-15
Recommended Service Material.......................0A-15
Special Tool ......................................................0A-16
Maintenance and Tune-Up...................... 0B-1
Precautions...........................................................0B-1
Precautions for Maintenance ..............................0B-1
General Description.............................................0B-1
Recommended Oil and Lubricants......................0B-1
Scheduled Maintenance ......................................0B-2
Periodic Maintenance Schedule Chart................0B-2
Lubrication Point .................................................0B-3
Service Instructions.............................................0B-4
Engine Oil Level Check.......................................0B-4
Engine Oil Change and Engine Oil Filter
Replacement.....................................................0B-5
Gear Oil Change .................................................0B-7
Spark Plug Removal and Installation ..................0B-8
Spark Plug Inspection .........................................0B-9
Tappet Clearance (Valve Lash) Inspection
and Adjustment .................................................0B-9
Idle Speed Inspection........................................0B-15
Breather Line and Fuel Line Inspection ............0B-16
Low Pressure Fuel Filter Inspection..................0B-17
Low Pressure Fuel Pump Filter Replacement...0B-18
Water Pump and Water Pump Impeller
Inspection........................................................0B-18
Propeller / Propeller Nut and Cotter Pin
Inspection........................................................0B-19
Anode Inspection ..............................................0B-19
Bonding Wire Inspection ...................................0B-20
Battery Inspection .............................................0B-21
Thermostat Inspection.......................................0B-22
Bolts and Nuts Inspection .................................0B-22
Engine Holder Lubricating.................................0B-22
Oil Pressure Check ...........................................0B-23
Cylinder Compression Pressure Check ............0B-24