Suzuki DF350A Service Manual (English)

Other manuals for Suzuki DF350A

Service Manual27 pages

Owner's Manual232 pages

Questions and Answers:

M
Michael SpencerAug 17, 2025
Why won't my Suzuki Outboard Motor start?
- A
  angelahessAug 17, 2025
  If your Suzuki Outboard Motor won't start, several factors could be the cause. Here are a few things to check: * Make sure the fuel tank isn't empty and the fuel isn't old or deteriorated. * Ensure the engine starting procedure is correct and the fuel tank air vent is open. * Verify the fuel hose is properly connected, not kinked, and the fuel filter and tank filter aren't clogged. * The fuel pump may have failed, the spark plug could be fouled, or the ignition system may be faulty. * Also, check for loose electrical wiring connections.
P
Paul MarshallAug 20, 2025
How to fix a Suzuki Outboard Motor when the starter motor will not operate?
- H
  Holly CarrilloAug 20, 2025
  If the starter motor on your Suzuki Outboard Motor isn't working, consider the following potential solutions: * Ensure the emergency stop switch lock plate is correctly positioned. * Check if the starter relay fuse or sub battery cable fuse has blown. * Confirm the control handle is in NEUTRAL. * Inspect the battery terminal connection for corrosion or looseness and ensure the battery has power. * The starter motor itself may have failed. * If equipped with a Keyless Start System, the engine switch or start/stop switch might be faulty; otherwise, check the ignition switch or start/stop switch. * Also, check for any loose electric wiring connections.
M
matthewbaxterAug 22, 2025
What to do if my Suzuki Outboard Motor engine idles unstably or stalls?
- D
  Daniel OrtizAug 22, 2025
  If your Suzuki Outboard Motor engine idles unstably or stalls, there are several possible reasons: * The spark plug could be fouled, the fuel hose might be kinked or improperly connected, or the fuel could be deteriorated. * A clogged fuel filter or a failed fuel pump could also be the issue. * The ignition system may be faulty. * Using the incorrect engine oil or a failed thermostat can cause unstable idling. * Lastly, check for loose electric wiring connections.
R
Ronald FordAug 25, 2025
Why Suzuki Outboard Motor engine speed will not increase?
- D
  Denise JohnsonAug 26, 2025
  If the engine speed of your Suzuki Outboard Motor won't increase, consider these potential causes: * The propeller might be damaged, dirty, or improperly selected. * Ensure the outboard motor is correctly installed and the trim angle is properly adjusted. * Check for a fouled or incorrectly selected spark plug, a kinked fuel hose, or a clogged fuel filter. * The fuel could be deteriorated, or the fuel pump or ignition system might have failed. * The electronic throttle system could also be faulty. * Other factors include heavy cargo, water in the boat, or a dirty/damaged boat bottom.
M
matthewjohnsonAug 28, 2025
What does it mean when the caution system is activated on my Suzuki Outboard Motor?
- R
  Ricardo RuizAug 28, 2025
  If the caution system on your Suzuki Outboard Motor is activated (buzzer sounds, LEDs light up), it could indicate several issues: * A clogged cooling water passage, a failed thermostat, or a failed water pump. * The oil change reminder system might be activated, the engine oil level could be low or the oil deteriorated, or the oil pressure switch might be short-circuited. * A clogged engine oil filter or a failed oil pump. * Other potential causes include a damaged propeller, lost battery power, a failed engine control sensor, or loose electrical wiring connections.
S
Steven EdwardsAug 30, 2025
What to do if the Keyless Start System on my Suzuki Outboard Motor doesn't turn on and I hear three beeps?
- L
  Laurie DavisAug 30, 2025
  If the Keyless Start System on your Suzuki Outboard Motor doesn't activate and you hear three short beeps, consider these possibilities: * The keyless fob may be out of range, have a dead battery, or be in OFF mode. * The keyless fob might not be authenticated or there could be communication failure because of radio wave or noise. * There may be electric wiring connection failure between the keyless control unit and outboard motor. * There could be an authentication error between the keyless control unit and outboard motor, or an abnormality in the engine's electronic control system.
R
Robert TaylorSep 2, 2025
Why won't the Keyless Start System on my Suzuki Outboard Motor turn on, and I don't hear any beeps?
- J
  Jeffery MooreSep 2, 2025
  If the Keyless Start System on your Suzuki Outboard Motor fails to turn on and you don't hear the error sound (three short buzzer beeps), check the following: * Ensure the emergency stop switch lock plate is correctly positioned. * Inspect the battery terminal connection for corrosion or looseness and ensure the battery has power. * The keyless control unit or engine switch panel might be faulty. * Also, check for any loose electric wiring connections.
R
Rebecca ChambersSep 5, 2025
Why does my Suzuki Outboard Motor vibrate excessively?
- J
  John WarrenSep 5, 2025
  Excessive vibration in your Suzuki Outboard Motor can stem from a couple of issues: * The propeller might be damaged. * The engine mounting bolts or clamp screws could be loose.
B
brenda63Sep 7, 2025
What causes shift operation failure in a Suzuki Outboard Motor?
- E
  Emily ChavezSep 8, 2025
  If the shift operation on your Suzuki Outboard Motor won't activate, it could be due to: * A failure in the electronic shift control system. * Shift Link Breakage or Coming-off.
C
Chad JohnsonSep 12, 2025
How to fix Suzuki Outboard Motor Keyless Start System that does not turn off?
- J
  joseph21Sep 12, 2025
  If the Keyless Start System on your Suzuki Outboard Motor doesn't turn off, it might be due to: * Loose electric wiring connections. * Engine switch panel failure.

Suzuki DF350A Specifications

General

Maximum Output	257.4kW (350PS)
Fuel Delivery System	Electronic Fuel Injection
Starting System	Electric
Steering	Remote
Gear Ratio	2.29:1
Lubrication System	Wet sump
Engine Mounting	Shear Mount
Displacement	4, 390 cm3 (267.9 cu. in.)
Bore x Stroke	98 x 97 mm
Ignition System	Fully Transistorized
Shaft Length	X: 635mm (25 in.), XX: 762mm (30 in.)
Oil Capacity	8.0 L (8.5 US qt.)
Alternator	12V 54A
Weight	330 kg (727 lbs)
Exhaust	Through Propeller Hub
Engine Type	4-stroke, DOHC, V6
Recommended Fuel	Unleaded Gasoline (87 Octane Minimum)