50
General Maintenance
NOTE: Proper maintenance of the
ATV is important for optimum perfor-
mance. Follow the Maintenance
Schedule and all ensuing maintenance
and care instructions/information.
NOTE: Proper maintenance proce-
dures for each item can be found on
the corresponding page indicated.
If, at any time, abnormal noises, vibrations,
or improper functioning of any component
of this ATV is detected, DO NOT OPER-
ATE THE ATV. Take the vehicle to an
authorized dealer for inspection and adjust-
ment or repair.
A repair shop or person of the owner's
choosing may maintain, replace, or repair
emission-control devices and systems.
If the owner/operator does not feel quali-
fied to perform any of these maintenance
procedures or checks, take the vehicle to
an authorized dealer for professional ser-
vice.
I=Inspect and clean, adjust, lubricate,
replace as necessary
T=Tighten, R=Replace, C=Clean
* Dealer maintenance ** When using ACX
All Weather synthetic oil, oil change inter-
val can be increased to every 1,000 miles
or every year.
Maintenance Schedule
Item Page
Initial
Service
(100 miles)
1 month 3 months 6 months
Battery 56 II
* Engine nuts and bolts - II
* Valve clearance - II
Spark plug 59 III
59 Replace every 4000 miles or 18 months
Liquid cooling system 51 I Inspect every time before riding
Throttle cable 53/59 I Inspect every time before riding
Gas Hoses 45 I Inspect every time before riding
Engine/transmission oil and filter 53 RR**
Air filter 59 II
Air filter housing drain(s) 60 I Inspect every time before riding
Gear lubricant (Front differential -
rear drive)
54 RI
54 Replace every 2 years or 2000 miles
V-Belt 60 II
Spark arrester/muffler 61 C
Tires/air pressure 61/
29
I Inspect every time before riding
* Brake components 54 I Inspect every time before riding
Brake fluid 54 I Inspect every time before riding
Brake hoses 55 I Inspect every time before riding
* Steering - I Inspect every time before riding
* Suspension (Ball joint boots, drive
axle boots front and rear, tie rods, dif-
ferential and rear drive bellows) - I Inspect every time before riding
* Chassis nuts and bolts - IT
Frame/welds/racks - II
Electrical connections - II
Headlight/taillight-brakelight 62 I Inspect every time before riding
Wheel nuts 61 II
To Next Page
Loading...
Need help?
General
