Toro 20073 - User Manual

Form No. 3357-441 Rev A
22in Recycler® Lawn Mower
Model No. 20073 —Serial No. 270000001 and Up
Model No. 20073A —Serial No. 270000001 and Up
Model No. 20074 —Serial No. 270000001 and Up
Model No. 20074A —Serial No. 270000001 and Up
Operator's Manual
Introduction
R ead this infor mation carefully to lear n ho w to operate and
maintain y our product properly and to a v oid injur y and
product damag e . Y ou are responsible for operating the
product properly and safely .
Y ou ma y contact T oro directly at www .T oro .com for
product and accessor y infor mation, help finding a dealer ,
or to register y our product.
W henev er y ou need ser vice , g en uine T oro par ts , or
additional infor mation, contact an A uthorized Ser vice
Dealer or T oro Customer Ser vice and ha v e the model and
serial n umbers of y our product ready . Figure 1 identifies the
location of the model and serial n umbers on the product.
Figure 1
1. Model and serial number plate
W rite the product model and serial n umbers in the space
belo w:
Model No.
Serial No.
T his man ual identifies potential hazards and has safety
messag es identified b y the safety aler t symbol ( Figure 2 ),
whic h signals a hazard that ma y cause serious injur y or
death if y ou do not follo w the recommended precautions .
Figure 2
1. Safety alert symbol
T his man ual uses 2 w ords to highlight infor mation.
Impor tant calls attention to special mec hanical infor mation
and Note emphasizes g eneral infor mation w or th y of special
attention.
Warning
CALIFORNIA
Pr oposition 65 W ar ning
T he engine exhaust fr om this pr oduct contains
chemicals kno wn to the State of Calif or nia to cause
cancer , bir th defects, or other r epr oducti v e har m.
Important: T his engine is not equipped with a
spar k ar r ester muf fler . It is a violation of Calif or nia
Public R esource Code Section 4442 to use or operate
the engine on an y f or est-co v er ed, br ush-co v er ed, or
g rass-co v er ed land. Other states or federal ar eas may
ha v e similar la ws.
T his spark ignition system complies with Canadian
ICES-002
T he enclosed Engine Owner’ s Man ual is supplied
f or inf or mation r egarding the US En vir onmental
Pr otection Agency (EP A) and the Calif or nia Emission
Contr ol R egulation of emission systems, maintenance,
and w ar ranty . R eplacements may be order ed thr ough
the engine man uf actur er .
F or models with stated engine horse po w er , the g ross
horse po w er of the engine w as laborator y rated b y the engine
man ufacturer in accordance with SAE J1940. As configured
to meet safety , emission, and operating requirements , the
actual engine horse po w er on this class of la wn mo w er will
be significantly lo w er .
© 2006—The Toro® Company
8111 Lyndale Avenue South
Bloomington, MN 55420
Register at www.Toro.com. Original Instructions (EN)
Printed in the USA.
All Rights Reserved

Toro 20073 Specifications

General

Cutting Width	22 in (56 cm)
Power Source	Gasoline
Deck Material	Steel
Weight	80 lbs (36.3 kg)
Engine	Briggs & Stratton
Engine Displacement	190cc
Drive System	Self-Propelled
Start Type	Recoil
Engine Type	4-Cycle
Type	Walk Behind Mower
Cutting Height	1.25 - 3.75 inches
Height Adjustment	Single-lever

Summary

Introduction to Toro Lawn Mower Operation

Safety Guidelines for Lawn Mower Use

General Operation Safety

Describes safe operating practices for the lawn mower.

Slope Operation Safety

Describes safe practices for mowing on slopes to prevent accidents.

Child Safety Precautions

Describes safety precautions regarding children around the mower.

Service and Maintenance Basics

Safe Gasoline Handling

Provides essential guidelines for safely handling gasoline fuel.

General Service Procedures

Outlines general maintenance checks and safety practices.

Safety and Instructional Decals

Highlights the importance and location of safety decals on the mower.

Lawn Mower Setup and Preparation

Unfolding the Handle

Details the procedure for unfolding the mower's handle for use.

Filling the Engine with Oil

Instructions for adding the correct type and amount of oil to the engine.

Installing the Fuse

Steps for installing the fuse required for electric start models.

Charging the Battery

Guidance on charging the mower's battery for electric start models.

Product Overview and Operation

Product Identification

Identifies key components of the lawn mower via a diagram.

Filling the Fuel Tank

Instructions for safely adding fresh unleaded gasoline to the mower.

Checking the Engine Oil Level

Procedure for verifying the engine oil level before operation.

Adjusting the Cutting Height

Steps to set the mower's cutting height for desired grass length.

Starting the Engine

Instructions for starting the mower's engine using primer and starter.

Using the Self-propel Drive

How to engage and use the self-propel feature for easier mowing.

Stopping the Engine

Procedure to safely shut down the mower's engine.

Recycling the Clippings

Information on using the mower for mulching grass clippings.

Bagging the Clippings

Instructions for collecting grass clippings using the attached bag.

Side-discharging the Clippings

Instructions for discharging grass clippings to the side of the mower.

Installing the Side Discharge Chute

Steps to attach the side discharge chute to the mower.

Removing the Grass Bag

Procedure to detach the grass collection bag from the mower.

Operating Tips for Lawn Mowing

General Mowing Tips

Provides general advice for effective and safe mowing practices.

Cutting Grass Effectively

Specific guidance on mowing different grass lengths and conditions.

Lawn Mower Maintenance Procedures

Recommended Maintenance Schedule

Outlines service intervals and required maintenance procedures.

Preparing for Maintenance

Steps to take before performing any maintenance tasks.

Changing the Engine Oil

Detailed steps for changing the engine oil for longevity.

Replacing the Air Filter

Instructions for replacing the air filter for optimal engine performance.

Charging the Battery

Guide for charging the mower's battery for electric start models.

Replacing the Fuse

Procedure for replacing a blown fuse for the electric starter system.

Lubricating Wheel Gears

How to lubricate the mower's wheel gears for smooth operation.

Replacing the Blade

Steps for safely removing and installing a new mower blade.

Adjusting Self-propel Drive Cable

How to adjust the self-propel drive cable for proper function.

Cleaning the Mower

Instructions for cleaning the mower after use to prevent rust and debris.

Lawn Mower Storage Guidelines

Preparing for Storage

Steps to prepare the mower for long-term storage, including fuel and battery.

Folding the Handle for Storage

Instructions for folding the mower handle for compact storage.

Removing from Storage

Steps to take when removing the mower from storage and preparing for use.

Toro Lawn Mower Warranty Information

Products Covered Under Guarantee

Details products and warranty periods for residential use.

Commercial Use Limited Warranty

Outlines the limited warranty for commercial lawn mower usage.

GTS-2 Engine Starting Guarantee

Guarantees engine starting for a specified period with proper maintenance.

Warranty Exclusions and Conditions

Lists items and conditions not covered by the Toro warranty.

Owner Responsibilities for Warranty

Specifies owner's duties, like maintenance, for warranty validity.

Obtaining Warranty Service

Instructions on how to contact service dealers and obtain warranty assistance.

General Warranty Conditions

Standard terms and conditions applicable to all Toro warranties.

International Warranty Information

How warranty applies and who to contact for Toro products outside US/Canada.