Toro TITAN ZX6000 - User Manual

60 pages

To Next Page

To Next Page

Loading...

FormNo.3394-243RevC

TITAN

®

ZX4800,ZX5400,or

ZX6000Zero-Turn-RadiusRiding

Mower

ModelNo.74861—SerialNo.315000001andUp

ModelNo.74862—SerialNo.315000001andUp

ModelNo.74863—SerialNo.315000001andUp

Registeratwww.Toro.com.

OriginalInstructions(EN)

*3394-243*C

Table of Contents

Other manuals for Toro TITAN ZX6000

Setup Instructions4 pages

Questions and Answers:

G
Gregory WilsonSep 9, 2025
Why aren't the blades rotating on my Toro Lawn Mower?
- J
  Jimmy RiceSep 9, 2025
  If the blades on your Toro Lawn Mower aren't rotating, it could be due to: * A worn, loose, or broken mower-deck belt: Install a new deck belt. * The mower-deck belt being off a pulley: Install the mower-deck belt and check the idler pulley, idler arm, and spring for correct position and function. * A worn, loose, or broken pump drive belt: Check the belt tension or install a new belt. * A broken or missing idler spring: Replace the spring.
K
Kelly MossSep 7, 2025
Why does my Toro TITAN ZX6000 Lawn Mower pull to one side?
- K
  Kelly BaldwinSep 7, 2025
  If your Toro Lawn Mower pulls to the left or right, it could be due to: * Tracking needing adjustment: Adjust the tracking. * Incorrect tire pressure in the drive tires: Adjust tire pressure in the drive tires.
M
michaelwilcoxAug 25, 2025
Why is the cutting height uneven on my Toro TITAN ZX6000?
- G
  Gregory McdanielAug 25, 2025
  Uneven cutting height on your Toro lawn mower can be caused by several factors. The blades might not be sharp, so sharpen them. Bent cutting blades can also cause this issue, so replace them if necessary. Ensure that the mower deck is level from side-to-side and front-to-rear. A dirty mower underside can also affect cutting height, so clean it. Finally, check and adjust the tire pressure to the correct levels.
B
Bradley FrazierSep 5, 2025
Why is my Toro TITAN ZX6000 vibrating so much?
- S
  sedwardsSep 5, 2025
  Excessive vibration in your Toro Lawn Mower can stem from several issues: * Bent or unbalanced cutting blades: Install new cutting blade(s). * Loose blade mounting bolt: Tighten the blade mounting bolt. * Loose engine mounting bolts: Tighten the engine mounting bolts. * Loose engine pulley, idler pulley, or blade pulley: Tighten the appropriate pulley.
J
Jesse EstradaSep 3, 2025
What to do if my Toro TITAN ZX6000 starter does not crank?
- S
  Sheila WeberSep 4, 2025
  If the starter on your Toro Lawn Mower isn't cranking, consider the following: * Ensure the blade control switch (PTO) is disengaged. * Confirm the parking brake is engaged. * Verify the drive levers are in the neutral lock position. * Make sure you are seated on the seat. * Check the battery charge and charge if necessary. * Inspect electrical connections for corrosion or looseness, ensuring good contact. * Replace the fuse if it's blown.
J
Jennifer RobertsonSep 2, 2025
Why is my Toro TITAN ZX6000 engine losing power?
- M
  Mark EspinozaSep 3, 2025
  If your Toro Lawn Mower's engine loses power, the engine load may be excessive, so reduce the ground speed. A dirty air cleaner can also cause this, so clean the air cleaner element. Additionally, check the oil level and add oil to the crankcase if it is low. Make sure the cooling fins and air passages above the engine are free from obstructions. You may also need to clean or replace the fuel cap or replace the fuel filter.
D
dixontrevorSep 1, 2025
What to do if Toro TITAN ZX6000 blades do not rotate?
- K
  Katherine HopkinsSep 1, 2025
  If the blades on your Toro lawn mower are not rotating, it could be due to a worn, loose, or broken mower deck belt; install a new deck belt. Another possible cause is the mower deck belt being off the pulley; install the mower deck pulley and check the idler pulley, idler arm, and spring for correct position and function. Also, check the pump drive belt for wear, looseness, or breakage; check the belt tension or install a new belt. Finally, inspect for a broken or missing idler spring and replace it if necessary.
G
gentryrobinAug 31, 2025
What to do if my Toro Lawn Mower won't drive?
- R
  Robin SparksAug 31, 2025
  If your Toro Lawn Mower isn't driving, first check if the bypass valves are open and close the tow valves. If this doesn't solve the problem, the traction belts may be worn, loose, or broken, or the traction belts are off the pulleys, or the transmission has failed, and you should contact an Authorized Service Dealer.
A
Angela WilsonAug 30, 2025
How to fix a Toro Lawn Mower engine that is losing power?
- J
  john64Aug 30, 2025
  If your Toro Lawn Mower engine is losing power, begin by reducing the ground speed, as the engine load might be too high. Check the air cleaner and clean it if it's dirty. Ensure the oil level in the crankcase is adequate; add oil if needed. Inspect the cooling fins and air passages under the engine blower housing for any blockages and clear them. Replace the spark plug if it is pitted, fouled, or has an incorrect gap. If these steps don't resolve the issue, the fuel-tank vent may be blocked, there might be dirt in the fuel filter, or the fuel system may contain dirt, water, or stale fuel. In such cases, or if there is incorrect fuel in the fuel tank, you should contact an Authorized Service Dealer.
J
Jessica FosterAug 28, 2025
What to do if my Toro TITAN ZX6000 engine overheats?
- S
  Shawn MorrisAug 29, 2025
  If your Toro Lawn Mower engine is overheating, several issues could be the cause. Start by reducing the ground speed, as the engine load may be excessive. Then, check the oil level in the crankcase and add oil if it's low. Also, inspect the cooling fins and air passages under the engine-blower housing for obstructions and remove any you find. A dirty air cleaner can also cause overheating, so clean or replace the air-cleaner element. If the problem persists, there may be dirt, water, or stale fuel in the fuel system, and you should contact an Authorized Service Dealer.

Toro TITAN ZX6000 Specifications

General

Brand	Toro
Model	TITAN ZX6000
Category	Lawn Mower
Language	English

Summary

Toro Operators Manual

TITAN ZX4800, ZX5400, ZX6000 Mower Models

Identifies the specific mower models covered by this operator's manual.

Introduction to the Toro Mower

Important Safety Information

Highlights critical safety warnings and regulatory compliance for the mower and engine.

Safety Guidelines and Practices

Safe Operating Practices

Detailed instructions for safe operation of the riding mower, adapted from ANSI standards.

Safety and Instructional Decals

Explanation and location of safety symbols and decals on the machine.

Operator Controls and Features

Ignition, Throttle, and Choke Operation

Explains the function and operation of the ignition switch, throttle control, and choke.

Motion Control and Parking Brake

Details how to use the motion control levers and the parking brake for safe operation.

Mower Operation Procedures

Adding Fuel Safely

Provides instructions and warnings for safely adding fuel to the mower's tank.

Starting and Stopping the Engine

Step-by-step guide on how to safely start and stop the mower's engine.

Mower Usage and Transport

Safe Machine Transport

Guidelines for safely loading, securing, and transporting the mower on a trailer or truck.

Scheduled Maintenance

Maintenance Schedule Intervals

Provides a detailed schedule for maintenance tasks based on operating hours.

Engine Maintenance and Service

Servicing the Air Cleaner Element

Hydraulic System Maintenance

Checking Hydraulic Oil Level

Replacing Hydraulic System Filters

Mower Deck Maintenance

Servicing Cutting Blades

Guidance on inspecting, sharpening, and replacing mower blades for optimal cutting.

Troubleshooting Common Issues

Engine Starting Problems

Diagnoses and solutions for engine starting or running issues.

Mower Performance Issues

Related product manuals

Preview: Toro TITAN ZX6020

Toro TITAN ZX6020

Preview: Toro titan zx

Preview: Toro Titan ZX4800

Toro Titan ZX4800

Toro TITAN ZX4820

Preview: Toro TITAN ZX5000

Toro TITAN ZX5000

Preview: Toro Titan ZX4875

Toro Titan ZX4875

Preview: Toro TITAN ZX 5400

Toro TITAN ZX 5400

Preview: Toro TITAN ZX 4800

Toro TITAN ZX 4800

Preview: Toro Titan ZXM4875

Toro Titan ZXM4875

Preview: Toro 74920 TITAN ZX4820

Toro 74920 TITAN ZX4820

Toro 74924 TITAN ZX5420

Toro Titan Z4800 74812