EasyManua.ls Logo

Toro Wheel Horse 522xi - User Manual

Toro Wheel Horse 522xi
52 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
Operator’s Manual
IMPORTANT: Read this manual carefully. It contains information about your
safety and the safety of others. Also become familiar with the controls and
their proper use before you operate the product.
FORM NO. 3319–215
Wheel Horse
520xi Tractor
522xi Tractor
Model No. 73560 – 8900001 & UP
Model No. 73540 – 8900001 & UP

Table of Contents

Questions and Answers

  • P
    paul67Aug 19, 2025
    Why Toro Lawn Mower starter does not crank?
    • M
      Marcus SnyderAug 20, 2025
      The starter may not crank on your Toro Lawn Mower for several reasons. Ensure the PTO is OFF, the parking brake is set, and you are seated. Check for corroded or loose electrical connections and blown or loose fuses. If these steps don't resolve the issue, there may be a defective relay or switch, a discharged battery, a malfunctioning safety interlock system, a faulty starter or starter solenoid, or seized internal engine components.
  • C
    Christopher RojasAug 21, 2025
    What to do if Toro Wheel Horse 522xi Lawn Mower engine cranks but won't start?
    • A
      Alyssa JosephAug 21, 2025
      If your Toro Lawn Mower's engine cranks but doesn't start, first ensure you're following the correct starting procedure. Check if the fuel tank is empty and fill it with fresh fuel if needed. Make sure the fuel shut-off valve is open. Inspect the fuel system for dirt, water, or stale fuel, and drain and flush if necessary, then add fresh fuel. Also, check for a clogged fuel line and clean or replace it. Ensure the spark plug lead is connected and the spark plug isn't faulty; replace the spark plug if needed.
  • B
    Bradley WellsAug 25, 2025
    Why Toro Wheel Horse 522xi engine starts but does not keep running?
    • S
      Stanley LongAug 25, 2025
      If the engine of your Toro Lawn Mower starts but doesn't keep running, the fuel system may be the culprit. Dirt or water in the fuel system can cause this issue; drain and flush the system, then add fresh fuel. A clogged fuel filter could also be the problem, so replace it. Additionally, check for loose wires or poor connections and tighten them. A fuse may be blown or loose, so correct or replace it.
  • E
    Erica ScottAug 26, 2025
    How to fix Toro Lawn Mower engine losing power?
    • S
      samuel32Aug 26, 2025
      If your Toro Lawn Mower engine is losing power, start by checking the crankcase oil level and adjust it to the full mark. Inspect the air cleaner element for dirt and clean or replace it if necessary. Additionally, ensure that the fuel system is free of dirt, water, or stale fuel by draining and flushing it, then adding fresh fuel. Replace a faulty spark plug. Reduce ground speed if the engine load is excessive.
  • V
    Veronica EdwardsAug 28, 2025
    Why Toro Lawn Mower engine will not idle?
    • O
      ortizjillAug 28, 2025
      If your Toro Lawn Mower engine will not idle, dirt, water, or stale fuel in the fuel system could be the cause; drain and flush the system, then add fresh fuel. Replace the spark plug if it's faulty. Clean or replace the air cleaner element if it is dirty.
  • S
    Sarah BushAug 30, 2025
    What to do if Toro Wheel Horse 522xi Lawn Mower tractor operates in both directions, but with a loss of power?
    • P
      Paul PowellAug 30, 2025
      If your Toro Lawn Mower tractor operates in both directions but loses power, especially when the transmission gets hot, ensure the transmission oil level is at the full 'F' mark on the dipstick when the transmission is cold. Replace the transmission oil and filter if the transmission shows signs of overheating or water contamination. Increase the engine speed to full throttle.
  • R
    Robert AllenSep 1, 2025
    Why Toro Wheel Horse 522xi Lawn Mower tractor goes forward only at partial speed and is slow or does not operate in reverse?
    • M
      mike81Sep 1, 2025
      If your Toro Lawn Mower tractor only goes forward at partial speed or is slow/doesn't operate in reverse, turn the cruise control off if it was engaged when the traction pedal was in neutral. Move the throttle to 'FAST' if the engine is running at partial speed.
  • L
    Linda CampbellSep 3, 2025
    What to do if Toro Wheel Horse 522xi Lawn Mower engine overheats?
    • S
      Susan NelsonSep 4, 2025
      If your Toro Lawn Mower engine overheats, ensure the crankcase oil level is correct by filling or draining to the full mark. Reduce excessive loading by using a lower ground speed. Clean the air intake screens and the cooling fins and air passages under the engine blower housing and/or the rotating air intake screen with every use.
  • L
    Lisa RodriguezSep 5, 2025
    Why Toro Lawn Mower engine runs but knocks or misses?
    • M
      matthew04Sep 6, 2025
      If your Toro Lawn Mower engine runs, but knocks or misses, it might be due to several reasons. First, check for dirt, water, or stale fuel in the fuel system; if present, drain and flush the system, then add fresh fuel. Ensure the spark plug lead is securely connected. Replace the spark plug if it is faulty. Also, check for loose wires or poor connections and tighten them. Finally, consider if the engine is overheating.
  • J
    joseph72Sep 8, 2025
    How to solve Toro Wheel Horse 522xi Lawn Mower abnormal vibration or noise?
    • M
      Melissa HallSep 8, 2025
      To address abnormal vibration or noise in your Toro Lawn Mower, begin by checking the engine mounting bolts and tighten them if they are loose. Also, inspect the idler pulley or cutter deck blade for looseness and tighten the appropriate pulley.

Toro Wheel Horse 522xi Specifications

General IconGeneral
Horsepower22 HP
Cutting Width52 inches
TransmissionHydrostatic
Drive2WD
Turning Radius18 inches
EngineKohler
Engine Type4-cycle
Deck TypeSide Discharge
Cutting Height1.5 - 4.5 inches
Speed Range0 - 7 mph

Related product manuals