Home
Trane
Air Conditioner
4DCZ6036
Page 4 (Step 2-Determine Unit Clearances)
Trane 4DCZ6036 - Step 2-Determine Unit Clearances
28 pages
Manual
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
P
age
4
Installer’s Guide
Step 2—Determine Unit Clearances
Figure 1. 4DCZ6036 (1 of 3)
Figures 1 through 6 show the unit critical dimensions.
NO
TE:
The view labeled “Bottom
Side”
represents the Base
as viewed looking up from
underneath the unit.
3
5
Table of Contents
Main Page
Safety Considerations
2
Table of Contents
3
Introduction
3
Step 1-Inspect Shipment
3
Step 2-Determine Unit Clearances
4
Step 3-Review Location and Recommendation Information
10
Step 4-Unit Installation
11
Install Flue Hood
11
Ground Level Installation
11
Rooftop Installation -- Curb Mounting
11
Covert Horizontal Airflow to down Airflow
11
Install Full Perimeter Roof Mounting Curb
11
Lifting and Rigging
12
Placing the Unit on the Mounting Curb
12
Rooftop Installation -- Frame Mounting
13
Rooftop Installation -- no Frame/Curb
13
Ductwork Installation
16
Attaching Downflow Ductwork to Roof Curb
16
Attaching Downflow Ductwork to Roof Frame
16
Attaching Horizontal Ductwork to Unit
16
Condensate Drain Piping
16
Gas Piping Installation
16
Pipe Delivery Schedule (Natural Gas Only)
17
Gas Pressure Set-Up Precautions
17
Gas Supply Line Pressure (All Fuels)
17
Manifold Pressure
18
Input Check and Adjustment
18
High Altitude Installation
19
Air Filter Installation
19
Electrical Wiring
19
Electrical Connections
19
Electrical Power
19
Disconnect Switch
19
Over Current Protection
19
Power Wiring
19
Control Wiring (Class II)
20
Thermostat
20
Field Wiring Diagram
22
Step 5-Unit Startup
23
Pre-Start Quick Checklist
23
Starting the Unit in the Cooling Mode
23
Operating Pressures
23
Voltage Check
23
Cooling Shutdown
23
Starting the Unit in Heat Pump Heating Mode
23
Gas Furnace Heating Cycle
23
Starting the Unit in Gas Heating Mode
24
Heating Shut-Down
24
Final Installation Checklist
24
Sequence of Operation
24
Maintenance
27
Owner Maintenance
27
Filters
27
Service Maintenance
27
Cooling Season
27
Heating Season
27
Flue Hood Cleaning
27
ECM Fan Motor Adjustments
28
Status Leds
28
Related product manuals
Trane 4DCZ5024F1060A
40 pages
Trane 4DCY4024
28 pages
Trane 4DCY4030
28 pages
Trane 4DCY4042
28 pages
Trane 4DCY4048
28 pages
Trane 4TTR3
22 pages
Trane 4TTR4
8 pages
Trane 4TTZ0
32 pages
Trane 4TTX8
26 pages
Trane 4MXW6-A
20 pages
Trane 4MCW3-A
20 pages
Trane XR16 4TTR6
16 pages
To Next Page
Loading...
