Trane CXAU - Page 3

Preface
3PKGP-SVX19A-EN
Modular Air-Cooled Chiller (Heat Pump) Installation Completion
Check Sheet for Application of Trane Service
Installation Company:
Installation Company Address:
Owner Name/Company:
Contact: Telephone:
Unit Installation Address:
Unit Model:
IDU Barcode:
ODU Barcode:
Dealer: Contact:
Telephone : Fax:
Installation Company : Contact:
Telephone : Fax:
Check List
Please read the installation manual and relevant installation specications before installation
1. Conrmation of the installation
a) Ventilation of the outdoor unit meets the distance requirements in the manual Yes ( ) No ( )
b) Installation meets platform requirements and isolation pads installed for outdoor unit Yes ( ) No ( )
c) Isolation pads installed for indoor unit Yes ( ) No ( )
d) Enough service clearance around the unit Yes ( ) No ( )
e) Not installed in abnormal acidity or alkaline places such as seaside (except for relevant customized
units)
Yes ( ) No ( )
2. Conrmation of the installation of the unit’s electrical system
a) Air switch capacity and power cable diameter meet the requirements of the unit Yes ( ) No ( )
b) Wiring is correct and terminal blocks are pressed tightly without false connections Yes ( ) No ( )
c) Connection of the neutral wire to the ground wire complies with the relevant electrical specications Yes ( ) No ( )
d) Wiring connection between the control line and the power line meets the anti-interference requirements Yes ( ) No ( )
e) ”ON-OFF” warning label is a󰀩xed to the air switch box of the power supply Yes ( ) No ( )
f) Terminal of external water pump overload protection is connected to the pump overload protection
terminal of the host water pump
Yes ( ) No ( )
3. Conrmation of the installation of the chilled water system
Yes ( ) No ( )
a) Prohibited to used in direct heating systems application (external continuous water replenishment) Yes ( ) No ( )
b) Designed by professional engineers (e.g. water pipe diameter calculation, etc.) Yes ( ) No ( )
c) The actual chilled water system resistance matches the pump head, and the water ow of the unit
reaches the rated value
Yes ( ) No ( )