WaterLogic WL350 - Installation Procedures Manual

WL350Manual Page44–Revision11‐21‐2018
PRE‐INSTALLATIONPROCEDURES


DANGER!ELECTRICALSHOCKHAZARD.
Onlyqualifiedpersonnelwhohavereadandunderstandthisentiremanualshouldattemptto
install,orservicethisunit,failuretodosocouldresultindeathorseriousinjury.DONOTplug
intoanelectricalsupplyuntilspecificallyinstructed.
 
WARNING!ALWAYSSANITIZEBEFOREUSE.
Sanitizebeforeusetoeliminateanypotentialmicrobiologicalcontaminates.

RedCompressor/HeaterSwitchmustbeintheO=OFFpositionwhiletheHot
Tankisempty.DamagecouldoccurwithinoneminuteandthetwoHotTank
OverloadDevices(HighSafetyLimit)requiremanualresetifheateristurned
onwithanemptyHotTank.

CAUTION!DRIPTRAYDRAIN.
Ifyouintendtoprovideadriptraydrainforyourcustomer,beawarethatyou
willbecalledmultipletimespermonthtoserviceandunclogthetubing
leadingawayfromthedriptraytodrain.Userswillclogthedrainwithpaper
clips,erasers,napkins,teabags,gum,andvariousotherintendeditems.
Waterlogicrecommendsyouestablishaminimumofweeklyvisitstothe
machineforcleaningofthedriptraydrain.

MaterialsNeeded:
 PersonalProtectiveEquipment.RubberorNitrileSafetyGlovesandProtectiveEyewear
 PhillipsScrewdriver
 TemperatureGauge
 WaterPitcherorContainertocollectwaterfromthefaucet
 16Liter(5gallon)containerordrainbasin
 Sanitizer‐HouseholdBleach(5.25%SodiumHypochlorite)orCitricAcidBasedCleaner
 ¼”PlasticTubing,atleast4feetinlength,andassorted¼”quickconnectfittings
 TDSMeterandTestStripsformeasuringchlorine–Optional
 SanitizingCartridge

1. UnpacktheWaterlogicWL350WaterTreatmentSystemsandcheckexteriorfordamage.
 
Sanitizing

SanitizeusingaHouseholdBleach(5.25%SodiumHypochloritesolution)orotherapproved
cleanerthroughoutthecoldandsparklingwatercircuits.Followallinstructionsonthesanitizer
andflushwithfreshwaterthroughthefaucetuntilodorandtasteisacceptable.
