Yamaha GLADIATOR - Page 6

TABLE OF CONTENTS
Air filter........................................................... 6-10
Carburetor adjustment ................................. 6-11
Idle speed adjustment ................................. 6-12
Throttle cable free play adjustment ............. 6-12
Valve clearance adjustment ......................... 6-13
Tyres .............................................................. 6-13
Wheels .......................................................... 6-15
Clutch lever free play adjustment ................ 6-16
Rear brake adjustment ................................ 6-17
Brake light switch adjustment ..................... 6-17
Checking front Brake Pads &
rear brake shoes .......................................... 6-18
Checking brake fluid level ............................ 6-18
Drive chain slack check................................ 6-19
Drive chain slack adjustment ...................... 6-20
Drive chain lubrication .................................. 6-22
Cable inspection and lubrication................. 6-22
Throttle cable and grip lubrication ............... 6-22
Brake and shift pedal lubrication ................. 6-23
Brake and clutch lever lubrication ................ 6-23
Center and sidestand lubrication ................ 6-23
Front fork inspection ..................................... 6-24
Steering inspection ....................................... 6-24
Wheel bearings ............................................ 6-25
Battery ........................................................... 6-25
Fuse replacement ........................................ 6-27
Headlight bulb replacement ........................ 6-28
Turn signal and taillight bulb
replacement.................................................. 6-29
Front wheel removal ..................................... 6-29
Front wheel installation ................................ 6-30
Rear wheel removal ..................................... 6-31
Rear wheel installation ................................ 6-33
Troubleshooting ........................................... 6-33
Troubleshooting chart .................................. 6-34
CLEANING & STORAGE ................................. 7-1
A. Cleaning ................................................... 7-1
B. Storage ...................................................... 7-2
SPECIFICATIONS ........................................... 8-1
CUSTOMER INFORMATION ........................... 9-1
Key identification number............................. 9-1
Frame serial number ................................... 9-1
Engine serial number .................................. 9-1
DETATCHMENTS
Pre-Delivey Inspection.................................... 10-1
Installation....................................................... 10-5
7
8
9
10
fazer5yy8.pmd 8/28/2006, 11:51 AM2