YASKAWA CDBR-****D

6 Electrical Installation
48 YASKAWA ELECTRIC TOBP C720600 01E YASKAWA AC Drive Option CDBR-D, LKEB- Installation Manual
■ Connection Diagram
WARNING! Fire Hazard. Perform all dynamic braking option wiring as specified in the provided wiring
diagrams. Improper wiring could cause death or serious injury.
Figure 20
Figure 20 Connection Diagram
<1> Set L8-55 to 0 to disable the protection function for the internal braking transistor when using a regenerative unit
or another type of dynamic braking option in lieu of the internal braking transistor. Enabling the protection
function under these conditions may cause a braking resistor fault (rF). This is not available for Varispeed
G7-series.
<2> Set L3-04 to 0 to disable Stall Prevention when using a regenerative converter, a regenerative unit, or a dynamic
braking option. Enabling the function under these conditions may prevent the drive from stopping within the
specified deceleration time.
<3> Set L8-01 to 1 to enable braking resistor overload protection in the drive when using ERF-type resistors.
<4> Be sure to protect non-Yaskawa braking resistors by thermal overload relay.
<5> Refer to the manual packaged with the drive for details on wiring ends.
Fault relay contact
Braking resistor
overheat switch
(thermal relay trip)
SA
12
TRX
MC
MA
TRX
SA
ON
OFF
THRX
MC
MC
SA
THRX
MC MB
Braking resistor
overheat switch
(thermal relay trip)
<1><2>
<5>
<2><3><4>
Level
sensor
LKEB Braking
Resistor Unit
CDBR Braking Unit
B1 P
12
B
B2
SC
SB
ELCB (MCCB)
R
T
S
MC
3-phase
R/L1
S/L2
T/L3
Main circuit
Drive
Wiring sequence should shut off
power to the drive when a CDBR
transistor short-circuit detection
output is triggered or when a
braking resistor unit overheat
switch is triggered.
M
U/T
1
V/T2
W/T
U
V
W
3
(Ground)
IN1 IN2 OUT1 OUT2
(Ground)
Fault output
250 Vac, max.1 A
30 Vdc, max.1 A
min.5 Vdc, 10 mA
(to customer circuit)
CDBR transistor
short-circuit
detection output
250 Vac, max.1 A
30 Vdc, max.1 A
min.5 Vdc, 10 mA
(to customer circuit)
MA MB MC EA EB EC
+
-
+3
-
TOBP_C720600_01E_9_0_E.book 48 ページ ２０１７年８月２５日 金曜日 午後２時８分