York MILLENIUM YCAS Series - Page 4

4
YORK INTERNATIONAL
TABLE OF CONTENTS (CONT’D)
SECTION 8 MICRO PANEL CONTENTS ...........................................................................................97
Chiller Control Panel Programming and Data Access Keys................................................... 97
Display and Status Information Keys ....................................................................................... 97
ON / OFF Rocker Switch ..........................................................................................................97
Program & Setup Keys .............................................................................................................97
1. INTRODUCTION & PHYSICAL DESCRIPTION .................................................................................98
1.1 General ..................................................................................................................... 98
1.2 Keypad & Display................................................................................................... 98
1.3 Unit (Chiller) On / OFF Switch ................................................................................ 99
1.4 Microprocessor Board ............................................................................................ 99
1.5 Ancillary Circuit Boards .......................................................................................... 99
1.6 Circuit Breakers ......................................................................................................100
1.7 Current Transformers (C.T.) ...................................................................................100
1.8 Transformers ..........................................................................................................100
1.9 Motor Protection Modules ....................................................................................101
1.10 EMS/BAS Controls ................................................................................................103
1.11 Microprocessor Board Layout ...............................................................................105
1.12 Logic Section Layout .............................................................................................106
1.13 Anti-Recycle Timer ................................................................................................107
1.14 Anti-Coincidence Timer .........................................................................................107
1.15 Evaporator Pump Control .......................................................................................107
1.16 Compressor Heater Control....................................................................................107
1.17 Evaporator Heater Control .....................................................................................107
1.18 Pumpdown (LLSV) Control ....................................................................................107
1.19 Alarms ....................................................................................................................107
1.20 Run Status (Chiller) ................................................................................................108
1.21 Lead / Lag Compressor Selection...........................................................................108
2. STATUS KEY: GENERAL STATUS MESSAGES AND FAULT WARNINGS ......................................109
2.1 General ....................................................................................................................109
2.2 General Status Messages .......................................................................................109
2.3 Unit Warnings ........................................................................................................110
2.4 Anticipation Control Status Messages..................................................................111
2.5 Unit Fault Status Messages...................................................................................112
2.6 System Fault (Safety) Status Messages ................................................................113
2.7 Printout on Fault Shutdown...................................................................................116
3. DISPLAY KEYS & OPTION SWITCHES ............................................................................................ 117
3.1 General ....................................................................................................................117
3.2 Chilled Liquid Temps Key ......................................................................................117
3.3 System # Data Keys ...............................................................................................118
3.4 Ambient Temp Key ................................................................................................118
3.5 Motor Current Key .................................................................................................119
3.6 Operating HRS / Start Counter Key .......................................................................119
3.7 Options Key & Dip Switch Settings ......................................................................119
3.8 Function Key .........................................................................................................121
4. PRINT KEYS .......................................................................................................................................122
4.1 General ....................................................................................................................122
4.2 Oper Data Key........................................................................................................122
4.3 Operating Data – Local Display Messages............................................................122
4.4 Operating Data – Remote Printout .........................................................................123
4.5 History Key ............................................................................................................125
4.6 Fault History Data – Local Display Messages ......................................................125
4.7 Fault History Data – Remote Printout ....................................................................128