York Sunline 2000 - Page 3

362242-YIM-B-0109
Johnson Controls Unitary Products 3
LIST OF FIGURES
Fig. # Pg. #
1 RECOMMENDED DRAIN PIPING . . . . . . . . . . . . . . . . 8
2 COMPRESSOR RESTRAINING BRACKET . . . . . . . . 8
3 TYPICAL FIELD POWER & CONTROL WIRING . . . . 9
4 ENTHALPY SETPOINT ADJUSTMENT . . . . . . . . . . 13
5 HONEYWELL ECONOMIZER CONTROL W7212 . . . 13
6 FOUR AND SIX POINT LOADING . . . . . . . . . . . . . . . 14
7 UNIT DIMENSIONS FRONT VIEW . . . . . . . . . . . . . . 27
Fig. #
Pg. #
8 UNIT WITH ECONOMIZER RAINHOOD . . . . . . . . . . 28
9 UNIT WITH FIXED OUTDOOR AIR/MOTORIZED
DAMPER RAINHOOD . . . . . . . . . . . . . . . . . . . . . . . . 28
10 UNIT DIMENSIONS (REAR VIEW) . . . . . . . . . . . . . . 29
11 DISCONNECT/BLOWER ACCESS LOCATION . . . . 29
12 BELT ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . 37
13 PRESSURE DROP ACROSS COIL . . . . . . . . . . . . . 38
14 UNIT CONTROL BOARD . . . . . . . . . . . . . . . . . . . . . 46
LIST OF TABLES
Tbl. # Pg. #
1 UNIT APPLICATION DATA (BP) . . . . . . . . . . . . . . . . . 6
2 CONTROL WIRE SIZES . . . . . . . . . . . . . . . . . . . . . . 10
3 ELECTRIC HEATER CFM LIMITATIONS . . . . . . . . . 10
4 PHYSICAL DATA . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
5 OPERATING WEIGHTS (LBS.) . . . . . . . . . . . . . . . . . 15
6 ELECTRICAL DATA - BP036-072 DIRECT DRIVE
W/O POWERED CONVENIENCE OUTLET . . . . . . . 15
7 ELECTRICAL DATA - BP036-072 BELT DRIVE W/O
POWERED CONVENIENCE OUTLET . . . . . . . . . . . 17
8 ELECTRICAL DATA - BP036-072 BELT DRIVE
HIGH STATIC W/O POWERED CONVENIENCE
OUTLET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
9 ELECTRICAL DATA - BP036-072 DIRECT DRIVE
W/POWERED CONVENIENCE OUTLET . . . . . . . . . 21
10 ELECTRICAL DATA - BP036-072 BELT DRIVE
W/POWERED CONVENIENCE OUTLET. . . . . . . . . . 23
11 ELECTRICAL DATA - BP036-072 BELT DRIVE
HIGH STATIC W/POWERED CONVENIENCE
OUTLET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
12 ELECTRIC HEAT CORRECTION FACTORS . . . . . . 27
13 VOLTAGE LIMITATIONS . . . . . . . . . . . . . . . . . . . . . . 27
14 UTILITIES ENTRY . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
15 MINIMUM CLEARANCES . . . . . . . . . . . . . . . . . . . . . 29
16 SUPPLY AIR BLOWER PERFORMANCE (BP036
BELT DRIVE) - SIDE DUCT APPLICATION . . . . . . . 30
Tbl. #
Pg #
17 SUPPLY AIR BLOWER PERFORMANCE (BP036
BELT DRIVE) - BOTTOM DUCT APPLICATION . . . 30
18 SUPPLY AIR BLOWER PERFORMANCE (BP048
BELT DRIVE) - SIDE DUCT APPLICATION . . . . . . . 30
19 SUPPLY AIR BLOWER PERFORMANCE (BP048
BELT DRIVE) - BOTTOM DUCT APPLICATION . . . 31
20 SUPPLY AIR BLOWER PERFORMANCE (BP060
BELT DRIVE) - SIDE DUCT APPLICATION . . . . . . . 31
21 SUPPLY AIR BLOWER PERFORMANCE (BP060
BELT DRIVE) - BOTTOM DUCT APPLICATION . . . 31
22 SUPPLY AIR BLOWER PERFORMANCE (BP072
BELT DRIVE) - SIDE DUCT APPLICATION . . . . . . . 32
23 SUPPLY AIR BLOWER PERFORMANCE (BP072
BELT DRIVE) - BOTTOM DUCT APPLICATION . . . 32
24 SUPPLY AIR BLOWER PERFORMANCE (BP036,
048, 060 & 072 DIRECT DRIVE) - SIDE FLOW
APPLICATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
25 SUPPLY AIR BLOWER PERFORMANCE (BP036,
048, 060 & 072 DIRECT DRIVE) - BOTTOM FLOW
APPLICATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
26 BELT DRIVE RPM SELECTION . . . . . . . . . . . . . . . . 34
27 BELT DRIVE BLOWER MOTOR AND DRIVE
DATA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
28 STATIC RESISTANCES . . . . . . . . . . . . . . . . . . . . . . 34
29 ELECTRIC HEAT LIMIT CONTROL SETTING . . . . . 42
30 ELECTRIC HEAT ANTICIPATOR SETPOINTS . . . . 42
31 UNIT CONTROL BOARD FLASH CODES . . . . . . . . 47