5402847-UIM-A-0917
Johnson Controls Unitary Products 33
SECTION XI: START UP SHEET
Water Heater BTUH Input Fan Assisted?
33" 80% AFUE Two Stage Gas Furnace Start Up Sheet
Proper furnace start up is critical to customer comfort and equipment longevity
Name Address
City State or Province Zip or Postal Code
Furnace Model Furnace Serial
Evaporator Coil Model Evaporator Coil Serial
Upflow Downflow Horizontal Left Horizontal Right
Unit is level
Venting system is the proper size, within the limitations of the chart in the
installation instructions, properly connected to the furnace, and properly pitched
Filter Type
Connector Size
Connector Length
# of 45 Degree Ells
# of 90 Degree Ells
Polarity is correct (black is L1 (hot), white is N (neutral)
Ground wire is connected
Line voltage to furnace (AC)
Low voltage value between "R" and "C" on furnace control board (volts AC)
Thermostat Type Other System Equipment and Accessories
Owner Information
Equipment Data
Furnace Configuration
Venting: B Vent
Electrical: Line Voltage
Outdoor Unit Model Outdoor Unit Serial
Filter, Thermostat, Accessories
Filter Location(s)
Connections -- All Per Installation Instructions and Local Code
Gas piping is connected (including drip leg) Supply plenum and return air are connected
Filter Size
Vent system is connected
Thermostat wiring is complete Thermostat heat anticipator set to .4 (6 cycle per hour for electronic thermostats )
Electrical: Low Voltage
Technician Performing Start-Up Installing Contractor Name
Start-Up Date
Continued on next Page
B Vent Connector
Connector Length
# of 45 Degree Ells
# of 90 Degree Ells
Connector Size
Venting: Lined Masonry Chimney
Other appliances in same common vent:
Vent Pipe Size
Furnace BTUH Input Fan Assisted?
Other BTUH Input Fan Assisted?
Vertical Termination
Total Height
Chimney Height
# of 45 Degree Ells
# of 90 Degree Ells
Vent Pipe Size
Y N
N
Y
Y N
Horizontal Term. (with External Power Vent)
Single Wall Connector
OFF 10 MIN 15 MIN 20 MIN
Thermostat Staging:
Thermostat:
To Next Page
Loading...
Need help?
General
