A.O. Smith BTH 300 - CONDENSATE DRAIN; CONDENSATE DRAIN WATER TRAP; CONDENSATE PH LEVEL; COMBUSTIBLE MATERIAL STORAGE

16
CONDENSATE DRAIN
7KH ZDWHU KHDWHUV FRYHUHG LQ WKLV PDQXDO DUH FRQGHQVLQJ
DSSOLDQFHVDQGUHTXLUHDEXLOGLQJGUDLQWREHORFDWHGLQFORVH
SUR[LPLW\WRDOORZWKHFRQGHQVDWHWRGUDLQVDIHO\
&RQGHQVDWHGUDLQVIURPWKHZDWHUKHDWHUDWWKHH[KDXVW
FRQGHQVDWHHOERZORFDWHGDWWKHERWWRP7KH¿HOGLQVWDOOHG
FRQGHQVDWHGUDLQOLQHPXVWQRWEHHOHYDWHGDERYHWKH
FRQGHQVDWHGUDLQFRQQHFWLRQRQWKHH[KDXVWFRQGHQVDWH
HOERZVHH)LJXUH,IWKHFRQGHQVDWHGRHVQRWGUDLQSURSHUO\
LWZLOOEXLOGXSLQWKHH[KDXVWYHQWHOERZ7KLVZLOOUHVWULFWWKH
ÀRZRIÀXHJDVHVDQGFDXVHWKH%ORFNHG([KDXVWSUHVVXUH
VZLWFKWR RSHQLWV FRQWDFWV 7KH FRQWURO V\VWHP PRQLWRUVDOO
SUHVVXUHVZLWFKHVLIWKH%ORFNHG([KDXVW6ZLWFKFRQWDFWV
DUHRSHQWKHFRQWUROV\VWHPZLOOORFNRXWDQGGLVDEOHKHDWLQJ
RSHUDWLRQ 7KH ³%ORFNHG ([KDXVW´ )DXOW PHVVDJH ZLOO EH
GLVSOD\HGRQWKHFRQWUROV\VWHP¶V/&'VHH)DXOW$QG$OHUW
&RQGLWLRQVEHJLQQLQJRQSDJH
7KH&RQGHQVDWH&OHDQRXW&DSPXVWEHRQDQGWLJKWZKHQXQLW
LVLQRSHUDWLRQ
7KH H[KDXVW HOERZ KDV D EXLOW LQ FRQGHQVDWH WUDS 'R QRW
LQVWDOODQDGGLWLRQDOWUDSLQWKHFRQGHQVDWHGUDLQSLSLQJ6HH
)LJXUH
NOTE: ,I WKH ³%ORFNHG ([KDXVW ³ )DXOW PHVVDJH LV HYHU
GLVSOD\HGRQWKHFRQWUROV\VWHP/&'FKHFNWKHFRQGHQVDWH
GUDLQ¿UVWDQGHQVXUHLWLVQRWEORFNHG
EXHAUST (VENT)
ELBOW
THIS SIDE VIEW
OF EXHAUST
ELBOW AND
ARROW INDICATE
THE LOCATION OF
THE PRESSURE
PORT
BUILDING
DRAIN
CONDENSATE
CLEANOUT CAP
CONDENSATE DRAIN
LINE - FIELD INSTALLED
CONDENSATE
DRAIN LINE
CONNECTION
DRAIN LINE TO TERMINATE NO
MORE THAN 6 INCHES (15.2cm)
ABOVE DRAIN
Figure 9
CONDENSATE DRAIN WATER TRAP
'R QRW UHPRYH WKH IDFWRU\ LQVWDOOHG H[KDXVWFRQGHQVDWH
HOERZ IRU DQ\ UHDVRQ VHH )LJXUH  7KH ZDWHU KHDWHU¶V
YHQWSLSHLVXQGHUDVOLJKWSRVLWLYHSUHVVXUHZKLOHXQLWLVLQ
RSHUDWLRQ7KHZDWHUWUDSSUHYHQWVIOXHJDVHVIURPHVFDSLQJ
LQWRWKHLQVWDOOHGVSDFH7KHH[KDXVWHOERZKDVDEXLOWLQ
FRQGHQVDWH WUDS 'R QRW LQVWDOO DQ DGGLWLRQDO WUDS LQ WKH
FRQGHQVDWH GUDLQ SLSLQJ 6HH )LJXUH  6HH &RQGHQVDWH
'UDLQ,QVWDOODWLRQRQSDJH
CONDENSATE PH LEVEL
7KHFRQGHQVDWHGUDLQVIURPWKHZDWHUKHDWHU¶VFRYHUHGLQ
WKLVPDQXDOKDYH3+OHYHOVEHWZHHQDQG,QVWDOOD
FRPPHUFLDOO\DYDLODEOHQHXWUDOL]LQJNLWLIUHTXLUHGE\ORFDO
FRGHV
NOTE:/RZHU3+OHYHOVDUHDFLGLF'RQRWFRQQHFWDPHWDO
GUDLQ OLQH VXFK DV FRSSHU WR WKH ZDWHU KHDWHU IRU WKLV
UHDVRQ6HH&RQGHQVDWH'UDLQ,QVWDOODWLRQRQSDJH
COMBUSTIBLE MATERIAL STORAGE
Fire or Explosion Hazard
Read instruction manual before
installing, using or servicing
water heater.
Avoid all ignition sources if you smell gas.
Do not store or use gasoline or other flammable vapors and
liquids in the vicinity of this or any other appliance.
Use only the gas shown on the water heater rating label.
Keep ignition sources away from faucets after extended
periods of non-use.
Maintain required clearances to combustibles.
Do not expose water heater controls to excessive gas
pressure.
.HHS DSSOLDQFH DUHD FOHDU DQG IUHH RI FRPEXVWLEOH PDWHULDOV
JDVROLQHDQGRWKHUÀDPPDEOHYDSRUVDQGOLTXLGV
CONTAMINATED AIR
Breathing Hazard - Carbon Monoxide Gas
Install water heater in accordance with
the Instruction Manual and NFPA 54 or
CAN/CSA-B149.1.
To avoid injury, combustion and ventilation
air must be taken from outdoors.
Do not place chemical vapor emitting
products near water heater.
Breathing carbon monoxide can cause brain damage or
death. Always read and understand instruction manual.
&RUURVLRQRIWKHÀXHZD\VDQGYHQWV\VWHPPD\RFFXULIDLUIRU
FRPEXVWLRQ FRQWDLQV FHUWDLQ FKHPLFDO YDSRUV 6XFK FRUURVLRQ
PD\UHVXOWLQIDLOXUHDQGULVNRIDVSK\[LDWLRQ
&RPEXVWLRQ DLU WKDW LV FRQWDPLQDWHG FDQ JUHDWO\ GLPLQLVK WKH
OLIH VSDQ RI WKH ZDWHU KHDWHU DQG ZDWHU KHDWHU FRPSRQHQWV
VXFKDVKRWVXUIDFHLJQLWHUVDQGEXUQHUV3URSHOODQWVRIDHURVRO
VSUD\V EHDXW\ VKRS VXSSOLHV ZDWHU VRIWHQHU FKHPLFDOV DQG
FKHPLFDOVXVHGLQGU\FOHDQLQJSURFHVVHVWKDWDUHSUHVHQWLQWKH
FRPEXVWLRQYHQWLODWLRQRUDPELHQWDLUFDQFDXVHVXFKGDPDJH
'RQRWVWRUHSURGXFWVRIWKLVVRUWQHDUWKHZDWHUKHDWHU$LUZKLFK
LVEURXJKWLQFRQWDFWZLWKWKHZDWHUKHDWHUVKRXOGQRWFRQWDLQDQ\
RI WKHVH FKHPLFDOV ,I QHFHVVDU\ XQFRQWDPLQDWHG DLU VKRXOG EH
REWDLQHGIURPUHPRWHRURXWGRRUVRXUFHV7KHOLPLWHGZDUUDQW\LV
YRLGHGZKHQIDLOXUHRIZDWHUKHDWHULVGXHWRDFRUURVLYHDWPRVSKHUH
6HHOLPLWHGZDUUDQW\IRUFRPSOHWHWHUPVDQGFRQGLWLRQV
,IWKHZDWHUKHDWHUZLOOEHXVHGLQEHDXW\VKRSVEDUEHUVKRSV
FOHDQLQJ HVWDEOLVKPHQWV RU VHOIVHUYLFH ODXQGULHV ZLWK GU\
FOHDQLQJHTXLSPHQWLWLVLPSHUDWLYHWKDWWKHZDWHUKHDWHUVEH
LQVWDOOHGLQD'LUHFW9HQWFRQ¿JXUDWLRQVRWKDWDOODLUIRUFRPEXVWLRQ
LVGHULYHGGLUHFWO\IURPWKHRXWGRRUDWPRVSKHUHWKURXJKDVHDOHG
LQWDNHDLUSLSH6HH9HQWLQJ,QVWDOODWLRQRQSDJH