A.O. Smith BTX-80 SERIES 100 - Page 8

A.O. Smith BTX-80 SERIES 100

40 pages

Save Page as PDF

To Next Page

To Next Page

To Previous Page

To Previous Page

Loading...

8

TYPICAL INSTALLATION

CONDENSATE HOSE AND DRAIN PAN

FIGURE 1 (continued).

Table of Contents

Instruction Manual1
For Your Safety1
Safe Installation, Use and Service2
Important Definitions2
Approvals2
General Safety Information3
Table of Contents5
Introduction5
- Qualified Installer Or Service Agency5
- Preparing for the Installation5
Installation Requirements for the Commonwealth of Massachusetts6
Typical Installation7
Rough in Dimensions10
Locating the New Water Heater11
- Facts to Consider about Location11
- Insulation Blankets12
- Air Requirements12
- Unconfined Space13
- Confined Space13
- Fresh Air Openings For Confined Spaces13
- Outdoor Air through One and Two Openings13
- Outdoor Air through Horizontal and Vertical Ducts14
- Air from Other Indoor Spaces14
Installing the New Water Heater15
- Chemical Vapor Corrosion15
- Water Piping15
- Space Heating and Potable Water System15
- Closed Water Systems15
- Thermal Expansion16
- Temperature-Pressure Relief Valve16
- Temperature-Pressure Relief Valve17
- High Altitude Installation17
- Gas Piping17
- Sediment Traps18
- Filling the Water Heater18
- Vent Pipe Assembly19
- Venting19
- Vent Pipe Termination20
- Planning the Vent System21
- Condensate21
- Condensate22
- Blower Assembly Installation22
- Installation of Vent System22
- Vent Terminal Installation, Sidewall22
- Installation of Vent System, Sidewall24
- Installation of Vertical Vent System24
- Vent Attenuation Assembly Installation Instructions25
- Vent Pipe Preparation27
- For Your Safety Read before Operating29
- Operating Instructions29
- To Turn off Gas to Appliance29
Lighting & Operating Label29
Temperature Regulation30
For Your Information31
- Start up Conditions31
- Operational Conditions31
Periodic Maintenance32
- Venting System Inspection32
- Burner Operation and Inspection32
- Burner Cleaning32
- Housekeeping32
- Anode Rod Inspection32
- Temperature-Pressure Relief Valve Test33
- Draining and Flushing33
- Service34
- Periodic Maintenance34
Leakage Checkpoints34
Troubleshooting Guidelines35
Trouble Shooting36
Limited Warranty39

Related product manuals

Preview: A.O. Smith BTX-80

A.O. Smith BTX-80

Preview: A.O. Smith BTX 100

A.O. Smith BTX 100

A.O. Smith BL-100

Preview: A.O. Smith 100 Series

A.O. Smith 100 Series

Preview: A.O. Smith SERIES 100

A.O. Smith SERIES 100

Preview: A.O. Smith Master-Fit 100 Series

A.O. Smith Master-Fit 100 Series

Preview: A.O. Smith Cyclone XL 100 Series

A.O. Smith Cyclone XL 100 Series

Preview: Vertex 100 Power Vent DV Series 120

Vertex 100 Power Vent DV Series 120

Preview: ProMax+plus High Efficiency SERIES 100

ProMax+plus High Efficiency SERIES 100

Preview: A.O. Smith BTH-120

A.O. Smith BTH-120

Preview: A.O. Smith BTH 300

A.O. Smith BTH 300

A.O. Smith Cyclone XL BTHS 1000A