© Copyright 2007, Alliance Laundry Systems LLC
All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without
the expressed written consent of the publisher.
70410501 1
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
Table of
Contents
Section 1 – Safety Information ...............................................................3
Locating An Authorized Service Person ...............................................4
Section 2 – Introduction..........................................................................5
Model Identification ..............................................................................5
Customer Service...................................................................................6
Serial Plate Location..............................................................................6
Safety Warnings and Decals..................................................................7
Safety Precautions for Servicing Tumblers...........................................7
How A Tumbler Works.........................................................................8
Section 3 – Troubleshooting..................................................................10
1. Motor Does Not Start..................................................................11
2. Motor Overload Protector Cycles Repeatedly ............................13
3. Motor Runs But Cylinder Does Not Turn...................................14
4. Motor Does Not Stop..................................................................15
5. Heating Element Does Not Heat Or Burner Does Not Ignite
– Gas and Electric Models ..........................................................16
6. Pilot Does Not Ignite – Standing Pilot Ignition Gas Models......18
7. Pilot Goes Out – Standing Pilot Ignition Gas Models ................19
8. Igniter Does Not Shut Off After Gas Ignition
– Automatic Pilot Ignition Gas Models ......................................20
9. Gas Supply Sufficient But Igniter Does Not Glow
– Glow-Bar Ignition Gas Models................................................21
10. Igniter Glows, Sensor Opens But No Ignition
– Johnson Controls System Gas Models.....................................22
11. Igniter Glows, Sensor Opens But No Ignition
– White Rodgers Glow-Bar Ignition Gas Models.......................23
12. Burner Ignites and Goes Out Repeatedly
– Glow-Bar Ignition Gas Models................................................24
13. Heating Element or Burner Shuts-Off Prematurely....................25
14. Heating Element or Burner Repeatedly Cycles Off On
High Limit Thermostat................................................................26
15. Heating Element or Burner Does Not Shut-Off..........................27
16. Clothes Do Not Dry ....................................................................28
17. Tumbler Overheating ..................................................................29
18. Burners Not Burning Properly – Gas Models.............................30
19. Loading Door Opens During Operation......................................31
20. Tumbler Runs But No Steam To Coils – Steam Models ............32
21. Water In Steam Line – Steam Models ........................................33
22. Troubleshooting Electronic Control Models...............................34
23. Tumbler Will Not Start, Time on Drying Timer,
Door Closed – Manual Timer Models ........................................36
24. Motor Runs, Time on Drying Timer But No Heat......................37
25. No Spark to Pilot Burner – Electronic Pilot Ignition Models.....39
26. Spark to Pilot Burner, No Pilot Flame
– Electronic Pilot Ignition Models..............................................40
27. Spark To Pilot Burner, Pilot Lights, No Main Burner
– Electronic Pilot Ignition Models..............................................41
To Next Page
Loading...
